Is your car affected?
Check by VIN to confirm the
exact model and see every recall for it.
Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
US recalls (1)
Exterior lighting: headlights
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Risk and remedy
Risk: If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy: GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
Canadian recalls (5)
Show 5 Canadian recalls
Electrical
2014-05-22 · campaign 2014-185
On certain vehicles, heat generated within the daytime running light (DRL) module could cause the module to melt, potentially resulting in a fire, which may result in injury and/or property damage. Correction: Dealers will inspect, and if necessary, replace the DRL module.
Lights and instruments
2012-08-13 · campaign 2012-274
On certain vehicles, the Daytime Running Lamp (DRL) module may fail, causing one or more of the following conditions: the DRLs may flicker but remain illuminated; the DRL indicator in the instrument panel may flash; the DRLs may remain illuminated after the vehicle is turned OFF; the DRLs may cease to function and the DRL indicator in the instrument panel will turn OFF. A loss of DRL illumination could render the vehicle less visible to other motorists and pedestrians during daylight hours, which could result in a crash causing property damage and/or personal injury. Correction: Dealers will replace the DRL module, if the above condition exists, for a period of up to 10 years or 240,000 km from first vehicle registration.
Engine
2007-08-28 · campaign 2007-275
On certain vehicles, the engine throttle may stick in the open position due to throttle body icing in temperatures near or below -20 degrees Celsius. If the throttle sticks open while the vehicle is moving, a crash could occur without prior warning. The vehicle may experience this condition even if one or both of the previous two campaign services have been performed. See recall 2005235 (GM 05521) & 2006239 (GM 06515). Correction: Dealers will replace the PCV and throttle body systems.
Engine
2006-09-28 · campaign 2006-239
On certain vehicles, the engine throttle may stick in the open position due to throttle body icing in temperatures near or below -20 degrees Celsius. If the throttle sticks open while the vehicle is moving, a crash could result without prior warning. Correction: Dealers will repair the PCV system update kit previously installed in recall 2005235 (GM 05521).
Other
2005-08-15 · campaign 2005-235
Certain vehicles may experience throttle body icing in conditions where temperatures are near or below -20 degrees Celsius. Vehicle with this conditions could have the throttle stick open after a cold soak or they can experience a frozen throttle while driving. Correction: Dealers will install new parts that integrate with the coolant system to heat the PCV lines and avoid PCV freezing.
Owner complaints (235)
Owners filed 235 complaints with NHTSA about the 2005 Chevrolet Aveo (19 crashes, 17 fires, 16 injuries, 1 deaths reported). Among 9 model years of this model, it ranks #1 for the most complaints (median 169).
| Most-reported problem | Complaints | |
|---|
| Electrical system | 67 | |
| Engine and engine cooling | 62 | |
| Exterior lighting | 48 | |
| Power train | 18 | |
| Engine | 17 | |
| Air bags | 16 | |
| Vehicle speed control | 16 | |
| Latches/locks/linkages | 13 | |
Crash test ratings
NHTSA 5-Star Safety Ratings for the 2005 Chevrolet Aveo.
| Version | Overall | Frontal | Side | Rollover |
|---|
| 2005 Chevrolet Aveo 4-DR. | – | – | – | – |
Fuel economy
EPA ratings for each 2005 Chevrolet Aveo version.
| Version | City MPG | Highway MPG | Combined | Yearly fuel cost |
|---|
| Aveo 1.6 L Automatic 4-spd | 23 | 31 | 26 | $2,600 |
| Aveo 1.6 L Manual 5-spd | 23 | 32 | 27 | $2,500 |
| Aveo 5 1.6 L Automatic 4-spd | 23 | 31 | 26 | $2,600 |
| Aveo 5 1.6 L Manual 5-spd | 23 | 32 | 27 | $2,500 |
Need this data in your app?
Recalls, complaints, crash ratings and fuel economy as a JSON API. Decode up to 50 VINs per call and get a daily feed of new recalls.
Explore the API →Sources: NHTSA recalls, complaints and 5-Star Safety Ratings, US EPA fuel economy and Transport
Canada's Vehicle Recalls Database (contains information licensed under the Open Government Licence – Canada).
Recalls updated 2026-10-30.