Is your car affected?
Check by VIN to confirm the
exact model and see every recall for it.
Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
US recalls (5)
Electrical system: ignition
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Risk and remedy
Risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Air bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Risk and remedy
Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Steering: electric power assist system
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Risk and remedy
Risk: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Structure
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Risk and remedy
Risk: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Exterior lighting: headlights
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE BULB SHIELDS INSIDE OF THE HEADLAMPS CAN LOOSEN DUE TO VIBRATION.
Risk and remedy
Risk: THE BULB SHIELD CAN LOOSEN OR BREAK BECAUSE OF VIBRATION. IF THIS OCCURRED ON A HEADLAMP INSTALLED IN A VEHICLE, ONCOMING DRIVERS MAY NOTICE ADDITIONAL GLARE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL TWO NEW HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON NOVEMBER 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Canadian recalls (5)
Show 5 Canadian recalls
Steering
2015-01-09 · campaign 2015-010
Certain vehicles equipped with electric power steering may experience a sudden loss of power steering assist that could occur at any time while driving. If the power steering assist is lost, a message is displayed on the Driver Information Centre and a chime sounds to inform the driver. Steering control can be maintained, as the vehicle will revert to a manual steering mode, but will require greater driver effort. The sudden change in steering may increase the risk of a crash causing injury and/or property damage. Correction: Dealers will affect repairs as necessary. Note: This recall is an expansion of recall 2014-104 for vehicles that may have received defective parts through prior servicing for recall 2010-059.
Other
2014-04-10 · campaign 2014-126
On certain vehicles, a defect may allow the ignition key to be removed from the ignition switch when the key is not in the "Off" position. This could result in unintended vehicle movement if the transmission is not in the "park" position (automatic transmission) or not in the reverse gear with the parking brake engaged (manual transmission), and increase the risk of a crash causing injury and/or property damage. Correction: Dealers will replace the ignition lock cylinder and/or ignition key.
Electrical
2014-02-10 · campaign 2014-038
On certain vehicles, a defect in the ignition switch could allow the switch to move out of the "run" position if the key ring is carrying added weight or the vehicle goes off-road or is subjected to some other jarring event. The timing of the key movement out of the “run” position, relative to the activation of the sensing algorithm of the crash event, may result in the airbags not deploying, increasing the risk of injury. Correction: Dealers will replace the ignition switch. Note: Until the correction is performed, all items should be removed from the key ring.
Steering
2010-03-02 · campaign 2010-059
Certain vehicles equipped with electric power steering may experience a sudden loss of power steering assist that could occur at any time while driving. If the power steering assist is lost, a message is displayed on the Driver Information Centre and a chime sounds to inform the driver. Steering control can be maintained, as the vehicle will revert to a manual steering mode, but will require greater driver effort. The sudden change in steering may increase the risk of a crash causing property damage, personal injury or death. Correction: Dealers will replace the electric power steering motor.
Lights and instruments
2004-11-24 · campaign 2004-412 · 376 vehicles
Certain vehicles fail to comply with the requirements of CMVSS 108 - Lamps, Reflective Devices, and Associated Equipment. Shields inside the headlamps became loose during a vibration test. If this occurred while under way, oncoming driver's may notice additional glare. Correction: Dealers will install two new headlamp assemblies.
Owner complaints (1,649)
Owners filed 1,649 complaints with NHTSA about the 2005 Chevrolet Cobalt (97 crashes, 12 fires, 72 injuries, 11 deaths reported). Among 13 model years of this model, it ranks #2 for the most complaints (median 2).
| Most-reported problem | Complaints | |
|---|
| Steering | 1,143 | |
| Electrical system | 323 | |
| Power train | 99 | |
| Air bags | 71 | |
| Engine | 69 | |
| Engine and engine cooling | 51 | |
| Suspension | 47 | |
| Structure | 46 | |
Crash test ratings
NHTSA 5-Star Safety Ratings for the 2005 Chevrolet Cobalt.
| Version | Overall | Frontal | Side | Rollover |
|---|
| 2005 Chevrolet Cobalt 2-DR | – | – | – | – |
| 2005 Chevrolet Cobalt 4-DR (Early release) | – | – | – | – |
| 2005 Chevrolet Cobalt 4-DR (Later release) | – | – | – | – |
Fuel economy
EPA ratings for each 2005 Chevrolet Cobalt version.
| Version | City MPG | Highway MPG | Combined | Yearly fuel cost |
|---|
| Cobalt 2.0 L Manual 5-spd | 20 | 27 | 23 | $3,550 |
| Cobalt 2.2 L Automatic 4-spd | 21 | 29 | 24 | $2,800 |
| Cobalt 2.2 L Manual 5-spd | 22 | 31 | 25 | $2,700 |
Need this data in your app?
Recalls, complaints, crash ratings and fuel economy as a JSON API. Decode up to 50 VINs per call and get a daily feed of new recalls.
Explore the API →Sources: NHTSA recalls, complaints and 5-Star Safety Ratings, US EPA fuel economy and Transport
Canada's Vehicle Recalls Database (contains information licensed under the Open Government Licence – Canada).
Recalls updated 2026-10-29.