Is your car affected?
Check by VIN to confirm the
exact model and see every recall for it.
Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
US recalls (4)
Fuel system, gasoline: storage
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Risk and remedy
Risk: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
Electrical system: ignition
ON CERTAIN SPORT UTILITY VEHICLES, CONTAMINATION ON IGNITION RELAY CONTACTS CAN CAUSE HIGH RESISTANCE. THIS CAN AFFECT SIGNALS TO THE POWERTRAIN CONTROL MODULE AND, COULD CAUSE INTERMITTENT VEHICLE STALLS AT ANY TIME.
Risk and remedy
Risk: THE VEHICLE CANNOT BE RESTARTED IMMEDIATELY. IF THIS WERE TO OCCUR, IT COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION RELAY FREE OF CHARGE. THE RECALL BEGAN ON MAY 4, 2005. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668 AND BUICK AT 1-866-608-8080.
Latches/locks/linkages: hatchback/liftgate, lock
ON CERTAIN SPORT UTILITY VEHICLES, A STRUCTURAL SUPPORT AT THE LATCH ATTACHMENT IN THE REAR LIFTGATE MAY BE INADEQUATE TO RETAIN THE LATCH TO THE LIFTGATE IN CERTAIN SEVERE VEHICLE CRASH EVENTS.
Risk and remedy
Risk: IF THE LIFTGATE WERE TO OPEN IN A VEHICLE CRASH, AN OCCUPANT COULD BE EJECTED FROM THE VEHICLE RESULTING IN INCREASED RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL ADD STRUCTURAL REINFORCEMENTS TO THE LIFTGATE IN THE AREA ADJOINING THE LATCH ASSEMBLY. OWNER NOTIFICATION SCHEDULE BEGAN ON JUNE 21, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080. THIS IS AN EXPANSION TO A PREVIOUS RECALL (03V211).
Fuel system, gasoline: storage
ON CERTAIN PASSENGER VEHICLES, A WELD BETWEEN THE FUEL TANK INLET CHECK VALVE AND THE FUEL TANK CAN FAIL.
Risk and remedy
Risk: IF THESE PARTS SEPARATE, THE DRIVER MAY NOTICE AN ODOR OF FUEL, THE SERVICE ENGINE SOON OR CHECK ENGINE LIGHT MAY ILLUMINATE, AND/OR FUEL MAY LEAK ONTO THE GROUND. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE SERIAL NUMBER OF THE FUEL TANK TO SEE IF IT IS ON THE LIST OF AFFECTED TANKS. IF THE SERIAL NUMBER MATCHES, THE FUEL TANK WILL BE REPLACED. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668.
Canadian recalls (4)
Show 4 Canadian recalls
Suspension
2006-08-15 · campaign 2006-199
On certain Aztek (AWD), Montana (AWD), Relay (AWD), RendezVous (AWD), RendezVous (FWD), Silhouette (AWD), Terraza (AWD), Terraza (FWD), Uplander (AWD) and Venture (AWD) vehicles equipped with independent rear suspension, when operated in extreme cold temperature and on rough roads, water and salt can intrude past the ball joint seal. The combination of theses conditions may then lead to premature wear of the ball joint. If the ball joint wear progresses to the point of separation from the lower control arm, a loss of vehicle control may occur. Correction: Dealers will replace both ball joints with new ball joints which have a revised boot and ball stud to improve the seal to the ball stud shaft.
Electrical
2005-04-21 · campaign 2005-113
On certain vehicles, contamination on ignition relay contacts can cause high resistance. This can affect signals to the powertrain control module, which could result in intermittent engine stalling. In some cases, the vehicle cannot be restarted immediately. If this were to occur, it could result in a vehicle crash. Correction: Dealers will replace the ignition relay.
Fuel system
2003-11-04 · campaign 2003-266 · 9 vehicles
On certain vehicles, a weld between the fuel tank inlet valve and the fuel tank was not made to specification and can fail. If these parts separate, the driver may notice an odour of fuel, the Service Engine Soon or Check Engine light may illuminate, and/or fuel may leak onto the ground. If a sufficient amount of fuel leaked and if an ignition source were present, a vehicle fire could occur. Correction: Dealer will inspect the fuel tank and replace it if necessary.
Structure
2003-06-16 · campaign 2003-147
On certain vehicles, a structural support at the latch attachment in the rear liftgate may be inadequate to retain the latch to the liftgate in certain severe vehicle crash events. If the liftgate were to open in a vehicle crash, an occupant could be ejected from the vehicle resulting in increased risk of personal injury. Correction: Dealer will add structural reinforcements to the liftgate in the area adjoining the latch assembly..
Owner complaints (200)
Owners filed 200 complaints with NHTSA about the 2004 Buick Rendezvous (14 crashes, 2 fires, 16 injuries, 2 deaths reported). Among 7 model years of this model, it ranks #3 for the most complaints (median 138).
| Most-reported problem | Complaints | |
|---|
| Electrical system | 76 | |
| Fuel system, gasoline | 23 | |
| Engine and engine cooling | 21 | |
| Fuel/propulsion system | 20 | |
| Steering | 16 | |
| Air bags | 14 | |
| Power train | 12 | |
| Service brakes | 11 | |
Crash test ratings
NHTSA 5-Star Safety Ratings for the 2004 Buick Rendezvous.
| Version | Overall | Frontal | Side | Rollover |
|---|
| 2004 Buick Rendezvous 4-DR. w/SAB | – | – | – | – |
Fuel economy
EPA ratings for each 2004 Buick Rendezvous version.
| Version | City MPG | Highway MPG | Combined | Yearly fuel cost |
|---|
| Rendezvous AWD 3.4 L Automatic 4-spd | 16 | 22 | 18 | $3,700 |
| Rendezvous AWD 3.6 L Automatic 4-spd | 16 | 23 | 19 | $3,550 |
| Rendezvous FWD 3.4 L Automatic 4-spd | 17 | 24 | 20 | $3,350 |
Need this data in your app?
Recalls, complaints, crash ratings and fuel economy as a JSON API. Decode up to 50 VINs per call and get a daily feed of new recalls.
Explore the API →Sources: NHTSA recalls, complaints and 5-Star Safety Ratings, US EPA fuel economy and Transport
Canada's Vehicle Recalls Database (contains information licensed under the Open Government Licence – Canada).
Recalls updated 2026-10-30.