Is your car affected?
Check by VIN to confirm the
exact model and see every recall for it.
Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
US recalls (4)
Air bags: frontal, sensor/control module-inactive
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, ALASKA AND THE DISTRICT OF COLUMBIA. THE FRONT CRASH SENSORS MAY CRACK UNDER CERTAIN ENVIRONMENTAL CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THIS CAN CAUSE THE SENSOR TO BECOME INOPERATIVE AND ILLUMINATE THE AIRBAG WARNING LIGHT. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE AIRBAG SYSTEM IN CERTAIN FRONTAL CRASHES.
Risk and remedy
Risk: IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.
Remedy: CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air bags: frontal, sensor/control module-inactive
CERTAIN MINIVANS ARE BEING RECALLED THAT WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE 27 STATES PLUS THE DISTRICT OF COLUMBIA THAT USE GREATER AMOUNTS OF SALT FOR WINTER ROAD DEICING. THE UP-FRONT (UF) AIR BAG SENSORS THAT CONTAIN BRASS BUSHINGS INSTALLED IN THESE VEHICLES MAY CORRODE AND CRACK ALLOWING WATER TO ENTER THE SENSOR. THESE SENSORS PROVIDE ENHANCED AIR BAG PERFORMANCE IN CERTAIN TYPES OF FRONTAL CRASHES.
Risk and remedy
Risk: IN ONE OF THESE CRASHES, WITH ONE OR BOTH OF THE VEHICLE'S UF SENSORS INOPERATIVE, THE OCCUPANTS WILL NOT BENEFIT FROM THE ENHANCED AIR BAG PROTECTION THAT THESE SENSORS WOULD PROVIDE.
Remedy: FOR VEHICLES REGISTERED IN THE RECALL STATES, DEALERS WILL REPLACE THE ORIGINAL UF AIR BAG SENSORS WITH ONES WITH GREATER CORROSION RESISTANCE. VEHICLES REGISTERED IN OTHER STATES WILL OBTAIN A LIFETIME FREE REPLACEMENT OF ANY UF SENSOR THAT FAILS. THE CAMPAIGN BEGAN ON JULY 2, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Visibility: windshield wiper/washer, motor
ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.
Risk and remedy
Risk: DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Seat belts: front, retractor
AFTER PERFORMING THE NCAP TEST, IT WAS DISCOVERED THAT ON CERTAIN MINIVANS EQUIPPED WITHOUT THE AVAILABLE "STOW 'N GO" SEATING OPTION, THE RIGHT FRONT SEAT BELT RETRACTOR ASSEMBLY MAY HAVE BEEN IMPROPERLY ASSEMBLED.
Risk and remedy
Risk: AS A RESULT, THE SEAT BELT MAY NOT PROPERLY RESTRAIN THE OCCUPANT DURING CERTAIN CRASH CONDITIONS, WHICH CAN INCREASE THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THE RETRACTOR ASSEMBLIES AND ANY SEAT BELT ASSEMBLY THAT DOES NOT HAVE THE STAKE WILL BE REPLACED. OWNER NOTIFICATION BEGAN ON FEBRUARY 23, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Canadian recalls (4)
Show 4 Canadian recalls
Other
2019-08-21 · campaign 2019-420
Issue:
This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones.
Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act.
Safety Risk:
Glass that breaks in to large pieces could create a risk of injury.
Corrective Actions:
The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.
Airbag
2007-05-30 · campaign 2007-169
On certain vehicles the left or right front supplemental airbag sensors may crack under certain conditions, which can allow water to enter into the sensor. This can cause the airbag warning lamp to illuminate. A malfunction of one or both of the supplemental sensors will not adversely affect safety or cause a failure to comply with government standards. The single-point sensor in these vehicles, which is located in the airbag control module, is operational even if both supplemental sensors are inoperative. DaimlerChrysler has decided to launch a Customer Satisfaction Notification to advise customers that these front airbag sensors will be replaced with redesigned sensors to reduce the potential for damage. This action is not being conducted under the Motor Vehicle Safety Act.
Other
2006-03-10 · campaign 2006-058
On certain vehicles, the front windshield wiper motor armature shaft may break which could result in a loss of front windshield wiping capability. This could impair the driver's vision and cause a crash without warning. Correction: Dealers will inspect and, if necessary, replace the front windshield wiper motor.
Seats and restraints
2004-02-06 · campaign 2004-050 · 331 vehicles
On certain vehicles, the front passenger seat belt retractor may have been improperly assembled. During a severe frontal impact, there is a possibility that the seat belt may not properly restrain the occupant which can increase the risk of injury. Correction: Dealer will inspect the retractor assembly, and replace if necessary.
Owner complaints (537)
Owners filed 537 complaints with NHTSA about the 2005 Dodge Caravan/Grand Caravan (19 crashes, 19 injuries reported). Among 34 model years of this model, it ranks #9 for the most complaints (median 191).
| Most-reported problem | Complaints | |
|---|
| Latches/locks/linkages | 203 | |
| Electrical system | 123 | |
| Exterior lighting | 90 | |
| Air bags | 49 | |
| Steering | 28 | |
| Fuel/propulsion system | 22 | |
| Suspension | 17 | |
| Structure | 15 | |
Crash test ratings
NHTSA 5-Star Safety Ratings for the 2005 Dodge Caravan/Grand Caravan.
| Version | Overall | Frontal | Side | Rollover |
|---|
| 2005 Dodge Caravan Early Release | – | – | – | – |
| 2005 Dodge Caravan Later Release | – | – | – | – |
Fuel economy
EPA ratings for each 2005 Dodge Caravan/Grand Caravan version.
| Version | City MPG | Highway MPG | Combined | Yearly fuel cost |
|---|
| Caravan/Grand Caravan 2WD 2.4 L Automatic 4-spd | 17 | 24 | 20 | $3,350 |
| Caravan/Grand Caravan 2WD 3.3 L Automatic 4-spd | 17 | 24 | 20 | $3,350 |
| Caravan/Grand Caravan 2WD 3.3 L Automatic 4-spd | 16 | 23 | 19 | $3,550 |
| Caravan/Grand Caravan 2WD 3.8 L Automatic 4-spd | 16 | 23 | 18 | $3,700 |
Need this data in your app?
Recalls, complaints, crash ratings and fuel economy as a JSON API. Decode up to 50 VINs per call and get a daily feed of new recalls.
Explore the API →Sources: NHTSA recalls, complaints and 5-Star Safety Ratings, US EPA fuel economy and Transport
Canada's Vehicle Recalls Database (contains information licensed under the Open Government Licence – Canada).
Recalls updated 2026-10-30.