Is your car affected?
Check by VIN to confirm the
exact model and see every recall for it.
Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
US recalls (2)
Latches/locks/linkages: doors, latch
ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.
Risk and remedy
Risk: AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING.
Remedy: DEALERS WILL INSTALL A SHIELD OVER THE FRONT LATCHES; SEAL A DRAIN HOLE IN THE REAR WINDOW TRIM MOLDING ON THE FREESTYLE REAR SIDE DOORS; AND APPLY GREASE TO ALL FRONT AND REAR SIDE-DOOR LATCH MECHANISMS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Fuel system, gasoline: storage, tank assembly
ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).
Risk and remedy
Risk: IF THIS HAPPENS, DRIVERS MAY NOTICE A NOISE OR A FUEL LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE BOTH FUEL TANK STRAPS. THE RECALL BEGAN ON DECEMBER 1, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Canadian recalls (2)
Show 2 Canadian recalls
Other
2006-10-19 · campaign 2006-273
On certain vehicles, the door latch mechanisms may experience water intrusion that, over time, may wash out grease applied during the manufacturing process. This may allow the latch mechanism to freeze during temperatures significantly below zero degrees Celsius, in combination with a wet environment. As a result, the door latch pawl may not return to the latched position when the door is closed, allowing the door to open while the vehicle is in motion. Correction: Dealers will: 1) install a shield over the front latches; 2) seal a drain hole in the rear window trim moulding on Freestyle rear side doors; and 3) apply grease to all front and rear side-door latch mechanisms.
Fuel system
2005-11-10 · campaign 2005-354
On certain vehicles, the fuel tank straps may break, potentially resulting in the fuel tank and fuel tank heat shield dropping on the exhaust system (FWD vehicles) or driveshaft (AWD vehicles). If the fuel tank and shield contact the exhaust or driveshaft, the driver may notice noise or a fuel leak. Fuel leakage in the presence of an ignition source may result in a fire. Correction: Dealers will replace both fuel tank straps.
Owner complaints (510)
Owners filed 510 complaints with NHTSA about the 2005 Ford Five Hundred (20 crashes, 6 fires, 14 injuries reported). Among 4 model years of this model, it ranks #1 for the most complaints (median 364).
| Most-reported problem | Complaints | |
|---|
| Power train | 136 | |
| Vehicle speed control | 104 | |
| Electrical system | 95 | |
| Engine | 58 | |
| Engine and engine cooling | 49 | |
| Service brakes, hydraulic | 41 | |
| Structure | 33 | |
| Fuel/propulsion system | 24 | |
Crash test ratings
NHTSA 5-Star Safety Ratings for the 2005 Ford Five Hundred.
| Version | Overall | Frontal | Side | Rollover |
|---|
| 2005 Ford Five Hundred 4-DR | – | – | – | 4★ |
Fuel economy
EPA ratings for each 2005 Ford Five Hundred version.
| Version | City MPG | Highway MPG | Combined | Yearly fuel cost |
|---|
| Five Hundred AWD 3.0 L Automatic (variable gear ratios) | 17 | 23 | 19 | $3,550 |
| Five Hundred FWD 3.0 L Automatic (variable gear ratios) | 18 | 25 | 20 | $3,350 |
| Five Hundred FWD 3.0 L Automatic 6-spd | 19 | 26 | 21 | $3,200 |
Need this data in your app?
Recalls, complaints, crash ratings and fuel economy as a JSON API. Decode up to 50 VINs per call and get a daily feed of new recalls.
Explore the API →Sources: NHTSA recalls, complaints and 5-Star Safety Ratings, US EPA fuel economy and Transport
Canada's Vehicle Recalls Database (contains information licensed under the Open Government Licence – Canada).
Recalls updated 2026-10-30.