Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
Park outsideService brakes, hydraulic: antilock/traction control/electronic limited slip, control unit/module
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Risk and remedy
Risk: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
Power train: axle assembly, axle shaft
Hyundai is recalling certain model year 2013 front wheel drive Santa Fe Sport vehicles manufactured July 13, 2012, through March 12, 2013; and equipped with 2.4 liter engines. Due to a manufacturing issue, the right front axle shaft may fracture.
Risk and remedy
Risk: A fractured front axle may result in a loss of power to the wheels. Additionally, if the vehicle is parked without the parking brake applied, it may roll away. Either condition increases the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the front axle shaft assembly, free of charge. The recall began on September 19, 2013. Owners may contact Hyundai Custom Care Center at 1-800-633-5151. Hyundai's recall number is 112.
Show 17 Canadian recalls
Label
2024-09-23 · campaign 2024-552
Issue:
On certain vehicles, the compliance label may be missing information in French. The words listed on the label for "Tires", "Rims", "Front" and "Rear" appear in English only, when they should be listed as "Tires/Pneus", "Rims/Jantes", "Front/Avant" and "Rear/Arriere". Canadian regulations require this information to be listed on the label in both English and French.
Safety Risk:
These small errors do not affect vehicle safety.
Corrective Actions:
This is not a recall. The company has corrected the compliance label for all new vehicles.
Brakes
2024-02-08 · campaign 2024-080
Issue:
On certain vehicles, brake fluid could leak into the control module for the antilock brake system (ABS) and cause it to short circuit.
Note: This recall replaces recall R0246 (Transport Canada recall number 2023-527). For the Sonata model, only the Sonata Hybrid model is affected by this recall.
Safety Risk:
A short circuit could create a fire risk, even while the vehicle is parked and turned off.
Corrective Actions:
Hyundai will notify owners by mail and advise you to take your vehicle to a dealership to replace the fuse for the ABS module. Hyundai recommends that you should park your vehicle outdoors and away from other vehicles or structures until the recall repairs have been completed.
Brakes
2023-09-22 · campaign 2023-527
This recall was replaced by Transport Canada Recall No. 2024-080.
Issue:
On certain vehicles, brake fluid could leak into the control module for the antilock brake system (ABS) and cause it to short circuit.
Safety Risk:
A short circuit could create a fire risk, even while the vehicle is parked and turned off.
Corrective Actions:
Hyundai will notify owners by mail and advise you to take your vehicle to a dealership to replace the fuse for the ABS module. Hyundai recommends that you should park your vehicle outdoors and away from other vehicles or structures until the recall repairs have been completed.
Brakes
2023-03-08 · campaign 2023-125
Issue:
Hyundai is conducting a special service campaign that provides anti-corrosion treatment to certain underbody components. Over time, components under the vehicle, including brake lines could corrode. If this happens, a brake line could fail and leak. A brake fluid leak can result in reduced braking.
Safety Risk:
Reduced braking can cause an extended stopping distance and increase the risk of a crash.
Corrective Actions:
Hyundai will notify owners by mail and advise you to take your vehicle to a dealership to inspect the underbody, including the brake lines. The dealer will apply an anti-corrosion treatment to certain parts, and replace the brake lines if necessary.
Electrical
2022-11-15 · campaign 2022-659
Issue:
On certain vehicles, the rear parking assist sensors (mounted in the rear bumper) could short circuit.
Note: This recall replaces Transport Canada recall 2022-118. Vehicles that were already repaired under Hyundai recall R0212 don't require this repair.
Safety Risk:
A short circuit could create a fire risk.
Corrective Actions:
Hyundai will notify owners by mail and instruct you to bring your vehicle to a dealership to replace the rear parking assist sensor fuse and any defective sensors. Hyundai recommends that if the instrument cluster does not work, the transmission shifter is stuck in park, or if you see melted plastic on the rear bumper, you should park the vehicle outside and contact a Hyundai dealer.
Accessories
2022-03-15 · campaign 2022-118
This recall was replaced by Transport Canada Recall No. 2022-659.
Issue:
On certain vehicles, the rear parking assist sensors (mounted in the rear bumper) could short circuit.
Note: Vehicles repaired under Hyundai recall R0078 (Transport Canada Recall No. 2013-067) also require this repair.
Safety Risk:
A short circuit could create a fire risk.
Corrective Actions:
Hyundai will notify owners by mail and instruct you to bring your vehicle to a dealership to replace the rear parking assist sensor fuse and any defective sensors. Hyundai recommends that if the instrument cluster does not work, the transmission shifter is stuck in park, or if you see melted plastic on the rear bumper, you should park the vehicle outside and contact a Hyundai dealer.
Brakes
2021-04-28 · campaign 2021-253
Issue:
On certain vehicles, brake fluid can enter the brake Hydraulic Electronic Control Unit (HECU) and cause a short circuit.
Note: This recall replaces R0172 (Transport Canada recall 2020-410). Vehicles that were repaired under that recall also require this repair.
Safety Risk:
A short circuit could create a fire risk.
Corrective Actions:
Hyundai will notify owners by mail and instruct you to take your vehicle to a dealer to have the HECU inspected and replaced if necessary. The dealer will also replace the ABS multi-fuse. Hyundai recommends that you should park your vehicle outdoors, and away from other vehicles or structures until the recall repairs have been completed.
Brakes
2020-09-01 · campaign 2020-410
This recall was replaced by Transport Canada Recall No. 2021-253.
Issue:
On certain vehicles, brake fluid can enter the brake Hydraulic Electronic Control Unit (HECU) and cause a short circuit.
Note: This problem may cause the ABS warning light to turn on.
Safety Risk:
A short circuit could create a fire risk.
Corrective Actions:
Hyundai will notify owners by mail and instruct you to take your vehicle to a dealer to have the HECU inspected and replaced if necessary. Hyundai recommends that you should park your vehicle outdoors, and away from other vehicles or structures until the recall repairs have been completed.
Electrical
2020-02-28 · campaign 2020-091
Issue:
Certain vehicles may be equipped with an accessory trailer wiring harness kit that could fail. Over time, moisture could enter the control module and cause a short circuit.
Note: This recall only affects Hyundai Genuine Accessory trailer wiring harness kits that were manufactured by third parties and sold in Canada. These kits may have been ordered at the time of a vehicle purchase, or purchased separately from a dealer as an aftermarket accessory.
Safety Risk:
A short circuit could create a fire risk. This risk remains even when the vehicle is parked.
Corrective Actions:
Hyundai will notify owners by mail and instruct you to inspect your vehicle to see if it has an affected trailer wiring harness installed. If it does, Hyundai will advise you to take your vehicle to a dealer to install a redesigned trailer wiring harness. Hyundai recommends that you should park your vehicle outdoors, and away from other vehicles or structures until the recall repairs have been completed.
Engine
2019-12-16 · campaign 2019-640
Issue:
Hyundai Auto Canada is conducting a Product Improvement Campaign that provides an update to the engine control module to detect potential problems before an engine fails. An engine failure would cause a sudden loss of power with an inability to restart.
Note: This affects Sonata and Santa Fe Sport equipped with a 2.4 L GDI or 2.0 L Turbo GDI engine, as well as Tucson equipped with a 2.4 L GDI engine.
Safety Risk:
A sudden loss of engine power could increase the risk of an accident.
Corrective Actions:
The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to update the software for the engine control module. Note: Vehicles previously repaired under Product Improvement Campaign R0153 (TC # 2019-130) do not require this software update.
Owners can find additional information at <a href="http://www.hyundaiengineinfo.ca">www.hyundaiengineinfo.ca</a>.
Other
2019-08-21 · campaign 2019-420
Issue:
This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones.
Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act.
Safety Risk:
Glass that breaks in to large pieces could create a risk of injury.
Corrective Actions:
The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.
Engine
2019-03-11 · campaign 2019-130
Issue:
Hyundai Auto Canada is conducting a Product Improvement Campaign that provides an update to the engine control module to detect potential problems before an engine fails. An engine failure would cause a sudden loss of power with an inability to restart.
Note: This affects Sonata and Santa Fe Sport equipped with a 2.4 L GDI or 2.0 L Turbo GDI engine, as well as Tucson equipped with a 2.4 L GDI engine.
Safety Risk:
A sudden loss of engine power could increase the risk of an accident.
Corrective Actions:
The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to update the software for the engine control module. Note: Vehicles repaired under Service Campaigns, C0336, C0344, or C0347, already have this software update.
Owners can find additional information at <a href="http://www.hyundaiengineinfo.ca">www.hyundaiengineinfo.ca</a>.
Engine
2019-01-10 · campaign 2019-012
Issue:
When repairs were completed under recall campaign 2015-428 (Hyundai #R0101) or 2017197 (Hyundai #R0130), the high pressure fuel pipe may not have been properly installed on the fuel pump outlet. A fuel leak could occur if the pipe was damaged, misaligned or improperly torqued during the recall repair.
Safety Risk:
Leaking fuel in the presence of an ignition source could increase the risk of a fire causing injury and/or property damage.
Corrective Actions:
The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer for an inspection. If fuel leakage is detected, the fuel pipe will be replaced with a new one.
Structure
2017-06-08 · campaign 2017-297
On certain vehicles, the cable between the actuating lever for the secondary hood latch and the secondary latch may become corroded over time. This could cause the secondary hood latch to remain in the open position when the hood is closed. If the vehicle were to be driven with the primary hood latch disengaged, or primary hood latch is released while driving, the secondary hood latch may not hold the hood closed while the vehicle is in motion. If this were to occur, it could compromise the driver’s ability to see the road and its users, as well as cause damage to the windshield. These issues could result in a crash causing injury and/or property damage. Correction: Dealers will replace the secondary hood latch cable.
Engine
2017-04-06 · campaign 2017-197
On certain vehicles equipped with 2.0L and 2.4L engines, the engine may contain residual metallic debris from factory machining operations. If debris is present, it could potentially restrict oil flow to the main bearings and rod bearings and could lead to premature wear. If the vehicle continues to be driven with worn bearings, the bearings could fail, which could cause an engine stall while the vehicle is in motion, resulting in loss of motive power which could increase the risk of a crash causing injury and/or property damage. Worn bearings could also result in the illumination of the oil pressure lamp in the instrument cluster. Correction: Dealers will inspect, and if necessary, replace the engine sub-assembly.
Powertrain
2013-08-12 · campaign 2013-279
On certain FWD Santa Fe Sport vehicles equipped with a 2.4L engine, the passenger side axle shaft could fail. This could result in a loss of vehicle propulsion which, in conjunction with traffic and road conditions, and the driver’s reactions, could increase the risk of a crash. This could also allow the vehicle to roll away if parked on a sufficient slope, despite the transmission shift lever being set in the PARK position. Both issues could result in property damage and/or personal injury. Correction: Dealers will replace the right front axle shaft assembly.
Accessories
2013-02-28 · campaign 2013-067
This recall was replaced by Transport Canada Recall No. 2022-118.
On certain Santa Fe Sport, a mixture of moisture and road salt may enter the rear parking assist sensors (mounted in the rear bumper), which could result in an electrical short on the circuit board within the sensor cavity. This could cause the sensors to overheat, which could result in a vehicle fire causing property damage and/or personal injury. Correction: Dealers will replace all four sensors for the Rear Parking Assist System.
Owners filed 605 complaints with NHTSA about the 2013 Hyundai Santa Fe (14 crashes, 41 fires, 13 injuries reported). Among 26 model years of this model, it ranks #3 for the most complaints (median 218).
NHTSA 5-Star Safety Ratings for the 2013 Hyundai Santa Fe.
EPA ratings for each 2013 Hyundai Santa Fe version.