Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
Park outsideService brakes, hydraulic: antilock/traction control/electronic limited slip, control unit/module
Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.
Risk and remedy
Risk: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.
Engine and engine cooling: engine
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.
Risk and remedy
Risk: The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.
Remedy: Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.
Latches/locks/linkages: hood, latch
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Risk and remedy
Risk: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
Seat belts: front, anchorage
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. In the affected vehicles, the bolt for the driver's seat belt anchor might not have been sufficiently tightened during assembly.
Risk and remedy
Risk: If the bolt was not sufficiently tightened, driver's seat belt may come unanchored in a collision, increasing the risk of injury to the occupant.
Remedy: Hyundai will notify owners and dealers will verify that the driver's seatbelt anchor is properly secured, free of charge. The recall began July 7, 2017. Owner's may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 165.
Tires: pressure monitoring and regulating systems
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
Risk and remedy
Risk: An underinflated inflated tire can increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.
Trailer hitches
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Risk and remedy
Risk: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Seat belts: front, warning light/devices
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Risk and remedy
Risk: Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.
Remedy: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.
Show 12 Canadian recalls
Label
2024-09-23 · campaign 2024-552
Issue:
On certain vehicles, the compliance label may be missing information in French. The words listed on the label for "Tires", "Rims", "Front" and "Rear" appear in English only, when they should be listed as "Tires/Pneus", "Rims/Jantes", "Front/Avant" and "Rear/Arriere". Canadian regulations require this information to be listed on the label in both English and French.
Safety Risk:
These small errors do not affect vehicle safety.
Corrective Actions:
This is not a recall. The company has corrected the compliance label for all new vehicles.
Brakes
2023-03-08 · campaign 2023-125
Issue:
Hyundai is conducting a special service campaign that provides anti-corrosion treatment to certain underbody components. Over time, components under the vehicle, including brake lines could corrode. If this happens, a brake line could fail and leak. A brake fluid leak can result in reduced braking.
Safety Risk:
Reduced braking can cause an extended stopping distance and increase the risk of a crash.
Corrective Actions:
Hyundai will notify owners by mail and advise you to take your vehicle to a dealership to inspect the underbody, including the brake lines. The dealer will apply an anti-corrosion treatment to certain parts, and replace the brake lines if necessary.
Brakes
2022-10-27 · campaign 2022-616
Issue:
On certain vehicles, the control module for the antilock brake system (ABS) could short circuit.
Note: This recall doesn't affect vehicles equipped with smart cruise control (SCC). This recall replaces Transport Canada recall 2022-046. Vehicles that were already repaired under Hyundai recall R0208 don't require this repair.
Safety Risk:
A short circuit could create a fire risk, even while the vehicle is parked and turned off.
Corrective Actions:
Hyundai will notify owners by mail and instruct you to take your vehicle to a dealer to replace the ABS multi-fuse. Hyundai advises that you may continue to drive your vehicle, however recommends that you should park it outdoors and away from other vehicles or structures until the recall repairs have been completed.
Brakes
2022-02-03 · campaign 2022-046
This recall was replaced by Transport Canada Recall No. 2022-616 due to increase in the number of recalled vehicles.
Issue:
On certain vehicles, the control module for the antilock brake system (ABS) could short circuit.
Note: This recall does not affect vehicles equipped with smart cruise control (SCC).
Safety Risk:
A short circuit could create a fire risk.
Corrective Actions:
Hyundai will notify owners by mail and instruct you to take your vehicle to a dealer to replace the ABS multi-fuse. Hyundai advises that you may continue to drive your vehicle, however recommends that you should park it outdoors and away from other vehicles or structures until the recall repairs have been completed.
Electrical
2020-02-28 · campaign 2020-091
Issue:
Certain vehicles may be equipped with an accessory trailer wiring harness kit that could fail. Over time, moisture could enter the control module and cause a short circuit.
Note: This recall only affects Hyundai Genuine Accessory trailer wiring harness kits that were manufactured by third parties and sold in Canada. These kits may have been ordered at the time of a vehicle purchase, or purchased separately from a dealer as an aftermarket accessory.
Safety Risk:
A short circuit could create a fire risk. This risk remains even when the vehicle is parked.
Corrective Actions:
Hyundai will notify owners by mail and instruct you to inspect your vehicle to see if it has an affected trailer wiring harness installed. If it does, Hyundai will advise you to take your vehicle to a dealer to install a redesigned trailer wiring harness. Hyundai recommends that you should park your vehicle outdoors, and away from other vehicles or structures until the recall repairs have been completed.
Engine
2019-12-16 · campaign 2019-640
Issue:
Hyundai Auto Canada is conducting a Product Improvement Campaign that provides an update to the engine control module to detect potential problems before an engine fails. An engine failure would cause a sudden loss of power with an inability to restart.
Note: This affects Sonata and Santa Fe Sport equipped with a 2.4 L GDI or 2.0 L Turbo GDI engine, as well as Tucson equipped with a 2.4 L GDI engine.
Safety Risk:
A sudden loss of engine power could increase the risk of an accident.
Corrective Actions:
The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to update the software for the engine control module. Note: Vehicles previously repaired under Product Improvement Campaign R0153 (TC # 2019-130) do not require this software update.
Owners can find additional information at <a href="http://www.hyundaiengineinfo.ca">www.hyundaiengineinfo.ca</a>.
Other
2019-08-21 · campaign 2019-420
Issue:
This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones.
Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act.
Safety Risk:
Glass that breaks in to large pieces could create a risk of injury.
Corrective Actions:
The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.
Engine
2019-03-11 · campaign 2019-130
Issue:
Hyundai Auto Canada is conducting a Product Improvement Campaign that provides an update to the engine control module to detect potential problems before an engine fails. An engine failure would cause a sudden loss of power with an inability to restart.
Note: This affects Sonata and Santa Fe Sport equipped with a 2.4 L GDI or 2.0 L Turbo GDI engine, as well as Tucson equipped with a 2.4 L GDI engine.
Safety Risk:
A sudden loss of engine power could increase the risk of an accident.
Corrective Actions:
The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to update the software for the engine control module. Note: Vehicles repaired under Service Campaigns, C0336, C0344, or C0347, already have this software update.
Owners can find additional information at <a href="http://www.hyundaiengineinfo.ca">www.hyundaiengineinfo.ca</a>.
Engine
2019-01-10 · campaign 2019-012
Issue:
When repairs were completed under recall campaign 2015-428 (Hyundai #R0101) or 2017197 (Hyundai #R0130), the high pressure fuel pipe may not have been properly installed on the fuel pump outlet. A fuel leak could occur if the pipe was damaged, misaligned or improperly torqued during the recall repair.
Safety Risk:
Leaking fuel in the presence of an ignition source could increase the risk of a fire causing injury and/or property damage.
Corrective Actions:
The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer for an inspection. If fuel leakage is detected, the fuel pipe will be replaced with a new one.
Structure
2017-06-08 · campaign 2017-297
On certain vehicles, the cable between the actuating lever for the secondary hood latch and the secondary latch may become corroded over time. This could cause the secondary hood latch to remain in the open position when the hood is closed. If the vehicle were to be driven with the primary hood latch disengaged, or primary hood latch is released while driving, the secondary hood latch may not hold the hood closed while the vehicle is in motion. If this were to occur, it could compromise the driver’s ability to see the road and its users, as well as cause damage to the windshield. These issues could result in a crash causing injury and/or property damage. Correction: Dealers will replace the secondary hood latch cable.
Seats and restraints
2017-06-08 · campaign 2017-298 · 805 vehicles
On certain vehicles, the bolt which fastens the driver’s seat belt anchor to the vehicle’s inner sill structure may not have been tightened to specification during assembly. This could result in the driver's seat belt possibly detaching from the anchor point. If the vehicle were to be involved in a collision, and the seat belt were to detach, it could increase the risk of injury to the seat occupant. Correction: Dealers will verify the proper connection between the driver’s seat belt anchor and to the vehicle’s inner sill structure.
Seats and restraints
2016-03-16 · campaign 2016-119
Certain vehicles may not comply with the requirements of Canada Motor Vehicle Safety Standard (CMVSS) 208 - Occupant Protection in Frontal Impacts. The wiring to the switch within the driver seat belt buckle which monitors whether the seat belt is buckled or unbuckled could become damaged by the seat's height adjuster mechanism. This could result in no audible signal (chime) or indicator light if the buckle is not fastened, or the chime and indicator light staying on when the seat belt is buckled. A lack of audible signal (chime) or indicator light may increase the likelihood of the vehicle being operated with an unfastened seat belt, which would increase the risk of injury in a crash. Correction: Dealers will inspect, and if necessary, reroute the harness to its proper location. Any harnesses with damage to the circuitry will be replaced.
Owners filed 971 complaints with NHTSA about the 2017 Hyundai Santa Fe (14 crashes, 23 fires, 18 injuries reported). Among 26 model years of this model, it ranks #1 for the most complaints (median 218).
NHTSA 5-Star Safety Ratings for the 2017 Hyundai Santa Fe.
EPA ratings for each 2017 Hyundai Santa Fe version.