Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
Fuel system, gasoline: delivery, hoses, lines/piping, and fittings
Hyundai Motor America (Hyundai) is recalling certain 2013-2014 Sonata vehicles. The low pressure fuel hose that connects the low pressure fuel pump to the direct injection fuel pump may crack over time, due to heat generated within the engine compartment.
Risk and remedy
Risk: A cracked fuel hose may leak fuel, which can increase the risk of a fire.
Remedy: Dealers will replace the low pressure fuel hose, free of charge. Owner notification letters were mailed October 10, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 227. This recall replaces NHTSA recall number 20V-121. Vehicles previously repaired under recall 20V-121 that did not receive a replacement fuel hose will need to have this new recall remedy performed.
Fuel system, gasoline: delivery, hoses, lines/piping, and fittings
Hyundai Motor America (Hyundai) is recalling certain 2013-2014 Sonata vehicles. The low pressure fuel hose that connects the low pressure fuel pump to the direct injection fuel pump may crack over time due to heat generated within the engine compartment.
Risk and remedy
Risk: If the fuel line cracks, a fuel leak can occur, increasing the risk of a fire.
Remedy: Hyundai will notify owners, and dealers will inspect the low-pressure fuel hose for damage or leaking, replacing it as necessary. If no damage or leaking is found, heat-protective tape will be installed. Repairs will be performed free of charge. The recall began August 10, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 189. This recall has been replaced by NHTSA recall number 22V-314.
Engine
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2013-2014 Santa Fe Sport vehicles previously repaired under recall numbers 15V-568 and 17V-226. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned, or improperly torqued during the engine replacement procedure, allowing fuel to leak from the pipe.
Risk and remedy
Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Hyundai will notify owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began March 1, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's recall number for this recall is 180.
Seat belts: pretensioner
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles previously repaired under recall campaign 17V-152. The seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
Risk and remedy
Risk: If the seat belt linkage detaches from the seat belt anchorage, it can not properly restrain the occupant in the event of a crash, increasing the risk of injury.
Remedy: Hyundai will notify owners, and dealers will again verify the connection between the seat belt linkage and the pretensioner and additionally install a warning label to prevent future seat belt linkage detachment, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 169.
Engine and engine cooling: engine
Hyundai Motor America (Hyundai) is recalling certain 2013-2014 Sonata and Santa Fe Sport vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine.
Risk and remedy
Risk: Bearing wear may result in the engine seizing, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will inspect the engine, replacing the engine short block, as necessary, free of charge. The recall began June 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 162.
Seat belts: front, anchorage
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles. In the affected vehicles, the seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
Risk and remedy
Risk: In the event of a crash, if the seat belts detach from the anchor pretensioners, it can increase the risk of injury.
Remedy: Hyundai will notify owners and dealers will inspect the connection between the seat belt linkages and the seat belt anchor pretensioners, repairing them as necessary, free of charge. The recall is expected to begin April 7, 2017. Owner's may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for the recall is 160.
Power train: automatic transmission
Hyundai Motor Company (Hyundai) is recalling certain model year 2011-2014 Sonata vehicles manufactured December 11, 2009, through May 29, 2014. In the affected vehicles, the transmission shift cable may detach from from the shift lever pin.
Risk and remedy
Risk: If the transmission shift cable detaches, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver parks the vehicle, despite selecting the 'PARK' position, the transmission may not be in 'PARK.' If the vehicle is not in the 'PARK' position and the parking brake is not applied, there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Hyundai will notify owners, and dealers will inspect and, as necessary, repair the connection between the shift cable and shift lever, free of charge. The recall began in September 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 123.
Show 12 Canadian recalls
Brakes
2024-02-08 · campaign 2024-080
Issue:
On certain vehicles, brake fluid could leak into the control module for the antilock brake system (ABS) and cause it to short circuit.
Note: This recall replaces recall R0246 (Transport Canada recall number 2023-527). For the Sonata model, only the Sonata Hybrid model is affected by this recall.
Safety Risk:
A short circuit could create a fire risk, even while the vehicle is parked and turned off.
Corrective Actions:
Hyundai will notify owners by mail and advise you to take your vehicle to a dealership to replace the fuse for the ABS module. Hyundai recommends that you should park your vehicle outdoors and away from other vehicles or structures until the recall repairs have been completed.
Electrical
2023-03-01 · campaign 2023-104
Issue:
Hyundai is conducting a special service campaign to upgrade the safety plug fuse. On certain Sonata Hybrid (HEV) models, the safety plug fuse in the power relay assembly could blow and cause a sudden loss of hybrid system power.
Safety Risk:
A loss of hybrid system power may increase the risk of a crash.
Corrective Actions:
Hyundai will notify owners by mail and instruct you to take your vehicle to a dealership to replace the 125-A safety plug with one that has a 150-A rating.
Fuel system
2022-05-07 · campaign 2022-242
Issue:
Over time, the fuel feed line to the high-pressure fuel pump could leak. If this happens, there could be a fuel odour or fuel leak in the engine compartment.
Note: This recall includes all vehicles that didn't have the fuel feed line replaced under recall R0166 (Transport Canada #2020-084).
Safety Risk:
A fuel leak can create the risk of a fire.
Corrective Actions:
Hyundai will notify owners by mail and instruct you to take your vehicle to a dealership to replace the fuel feed line.
Engine
2021-10-01 · campaign 2021-612
Issue:
Hyundai Auto Canada is conducting a Product Improvement Campaign that provides an update to the engine control module to detect potential problems before an engine fails. An engine failure would cause a sudden loss of power with an inability to restart.
Note: This only affects vehicles equipped with a 2.4 L MPI engine. For the Sonata model, only the Sonata Hybrid is affected by this campaign. All vehicles previously included in TC # 2021-033 are now part of this new campaign. Vehicles that were previously repaired under campaign R0181 (Transport Canada #2021-033) do not require this software update.
Safety Risk:
A sudden loss of engine power could increase the risk of an accident. An engine failure could also create the risk of a fire.
Corrective Actions:
The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to update the software for the engine control module.
Note: Hyundai recommends that you should always follow the correct vehicle maintenance schedule, which is printed in the Owner's Manual. If you experience unusual engine noise, reduced power, or a check engine/oil warning light, Hyundai advises you to immediately visit a Hyundai dealership to have your vehicle diagnosed.
Engine
2021-01-27 · campaign 2021-033
This campaign was replaced by Transport Canada No. 2021-612.
Issue:
Hyundai Auto Canada is conducting a Product Improvement Campaign that provides an update to the engine control module to detect potential problems before an engine fails. An engine failure would cause a sudden loss of power with an inability to restart.
Note: This only affects vehicles equipped with a 2.4 L MPI engine. For the Sonata model, only the Sonata Hybrid is affected by this campaign.
Safety Risk:
A sudden loss of engine power could increase the risk of an accident. An engine failure could also create the risk of a fire.
Corrective Actions:
The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to update the software for the engine control module.
Note: Hyundai recommends that you should always follow the correct vehicle maintenance schedule, which is printed in the Owner's Manual. If you experience unusual engine noise, reduced power, or a check engine/oil warning light, Hyundai advises you to immediately visit a Hyundai dealership to have your vehicle diagnosed.
Fuel system
2020-03-03 · campaign 2020-084
This recall was replaced by Transport Canada Recall No. 2022-242.
Issue:
Over time, the fuel feed line to the high-pressure fuel pump could crack. If this happens, there could be a fuel odour or fuel leak in the engine compartment.
Safety Risk:
A fuel leak can create the risk of a fire.
Corrective Actions:
Hyundai will notify owners by mail and instruct you to take your vehicle to a dealer to complete the required repairs.
Engine
2019-12-16 · campaign 2019-640
Issue:
Hyundai Auto Canada is conducting a Product Improvement Campaign that provides an update to the engine control module to detect potential problems before an engine fails. An engine failure would cause a sudden loss of power with an inability to restart.
Note: This affects Sonata and Santa Fe Sport equipped with a 2.4 L GDI or 2.0 L Turbo GDI engine, as well as Tucson equipped with a 2.4 L GDI engine.
Safety Risk:
A sudden loss of engine power could increase the risk of an accident.
Corrective Actions:
The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to update the software for the engine control module. Note: Vehicles previously repaired under Product Improvement Campaign R0153 (TC # 2019-130) do not require this software update.
Owners can find additional information at <a href="http://www.hyundaiengineinfo.ca">www.hyundaiengineinfo.ca</a>.
Engine
2019-03-11 · campaign 2019-130
Issue:
Hyundai Auto Canada is conducting a Product Improvement Campaign that provides an update to the engine control module to detect potential problems before an engine fails. An engine failure would cause a sudden loss of power with an inability to restart.
Note: This affects Sonata and Santa Fe Sport equipped with a 2.4 L GDI or 2.0 L Turbo GDI engine, as well as Tucson equipped with a 2.4 L GDI engine.
Safety Risk:
A sudden loss of engine power could increase the risk of an accident.
Corrective Actions:
The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to update the software for the engine control module. Note: Vehicles repaired under Service Campaigns, C0336, C0344, or C0347, already have this software update.
Owners can find additional information at <a href="http://www.hyundaiengineinfo.ca">www.hyundaiengineinfo.ca</a>.
Engine
2019-01-10 · campaign 2019-012
Issue:
When repairs were completed under recall campaign 2015-428 (Hyundai #R0101) or 2017197 (Hyundai #R0130), the high pressure fuel pipe may not have been properly installed on the fuel pump outlet. A fuel leak could occur if the pipe was damaged, misaligned or improperly torqued during the recall repair.
Safety Risk:
Leaking fuel in the presence of an ignition source could increase the risk of a fire causing injury and/or property damage.
Corrective Actions:
The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer for an inspection. If fuel leakage is detected, the fuel pipe will be replaced with a new one.
Engine
2017-04-06 · campaign 2017-197
On certain vehicles equipped with 2.0L and 2.4L engines, the engine may contain residual metallic debris from factory machining operations. If debris is present, it could potentially restrict oil flow to the main bearings and rod bearings and could lead to premature wear. If the vehicle continues to be driven with worn bearings, the bearings could fail, which could cause an engine stall while the vehicle is in motion, resulting in loss of motive power which could increase the risk of a crash causing injury and/or property damage. Worn bearings could also result in the illumination of the oil pressure lamp in the instrument cluster. Correction: Dealers will inspect, and if necessary, replace the engine sub-assembly.
Seats and restraints
2017-03-15 · campaign 2017-146
On certain vehicles, the connections between the front seat belts and the floor mounted seat belt anchor pretensioners may not have been attached properly during assembly. This could result in a front seat belt possibly detaching from the anchor pretensioner. If the vehicle were to be involved in a collision, and the seat belt were to detach, it could increase the risk of injury to the seat occupant. Correction: Dealers will verify the connection between the seat belt linkage and the anchor pretensioner’s cable connector for both front seat belts and repair as necessary. <b> Note: For the 2015 model year, it is only Sonata Hybrid models that are affected. </b>
Powertrain
2014-08-01 · campaign 2014-323
On certain vehicles equipped with automatic transmissions, the shift cable may detach from the shift lever. As a result, the driver may not be able to select a different gear position, or place the transmission in the PARK position. If the driver cannot place the vehicle in the PARK position and exits the vehicle without applying the parking brake, the vehicle could roll away, which could result in a crash causing injury and/or damage to property. Correction: Dealers will inspect the shift cable connection and repair as necessary.
Owners filed 750 complaints with NHTSA about the 2014 Hyundai Sonata (29 crashes, 40 fires, 35 injuries reported). Among 39 model years of this model, it ranks #7 for the most complaints (median 165).
NHTSA 5-Star Safety Ratings for the 2014 Hyundai Sonata.
EPA ratings for each 2014 Hyundai Sonata version.