Is your car affected?
Check by VIN to confirm the
exact model and see every recall for it.
Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
US recalls (4)
Vehicle speed control: cables
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Risk and remedy
Risk: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Wheels
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Risk and remedy
Risk: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Vehicle speed control: cables
ON CERTAIN MINI VANS, DURING ASSEMBLY, THE THROTTLE CABLE WOULD TWIST ITSELF OUT OF POSITION.
Risk and remedy
Risk: THIS CAN PERMIT THE CABLE TO BE HUNG UP, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE FREE OF CHARGE. VEHICLES PRODUCED FROM MARCH 20, 2001 THROUGH NOVEMBER 7, 2001 WILL HAVE A GUIDE CLIP INSTALLED ON THE THROTTLE BODY ASSEMBLY IN ORDER TO ENSURE THAT THE TENSION FORCE CABLE DOES NOT MOVE OUT OF POSITION. VEHICLES MANUFACTURED BEGINNING ON NOVEMBER 8, 2001, ALREADY HAVE THE EXTENDED GUIDE, WHICH ACCOMPLISHES THE SAME OBJECTIVE. THE RECALL BEGAN MARCH 21, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Service brakes, air: antilock, control unit/module
ON CERTAIN PASSENGER VEHICLES, THERE WAS A PROGRAMMING ERROR IN THE ANTI-LOCK BRAKING SYSTEM (ABS) ELECTRONIC CONTROL MODULE LOGIC. THE PROGRAMMING ERROR COULD CAUSE REDUCED BRAKING FORCE AT SPEEDS BELOW 25 MPH, WHICH COULD RESULT IN INCREASED STOPPING DISTANCES.
Risk and remedy
Risk: SUCH INCREASED STOPPING DISTANCES COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPROGRAM THE CONTROL MODULE. OWNER NOTIFICATION BEGAN MAY 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Canadian recalls (4)
Show 4 Canadian recalls
Electrical
2005-10-18 · campaign 2005-316
On certain vehicles, the wiring under the front seats of vehicles equipped with power seats could be misrouted, allowing the wire to be pinched by metal seat components. As a result, electrical resistance will trip a circuit breaker diode in the fuse junction box. After the diode cools down, it will reset and recycle through this process repeatedly. It may be possible for the diode to continue to build up heat instead of cooling down, which may result in a fire in another component in the junction box area. Correction: Dealers will inspect to confirm the integrity of the power seat wiring. In addition, the dealer will install corrugated tubing around the underseat wires to eliminate the possibility of wire pinching.
Engine
2005-08-08 · campaign 2005-228
On certain vehicles, water may enter between a protective rubber sleeve and the throttle cable towards the rear portion of the cable. If the ambient temperature drops below zero degrees Celsius, the water could freeze, causing the throttle to stick and the vehicle to accelerate unexpectedly. Correction: Dealers will modify the throttle cable rubber sleeve.
Other
2005-02-18 · campaign 2005-041
On certain vehicles, moisture can accumulate on the throttle cable. In freezing conditions, excessive moisture build-up can result in ice accumulation and resistance to movement. This can permit the throttle cable to be hung-up or to jump out of position, which could result in a crash. Correction: Dealers will replace the throttle cable.
Brakes
2003-07-02 · campaign 2003-164 · 813 vehicles
On certain vehicles, there was a programming error in the ABS control module logic. This programming error could cause reduced braking force at speeds below 40 Km/h (25 mph), resulting in increased stopping distances and the possibility of accidents. Correction: Dealer will reprogram the ABS control module.
Owner complaints (163)
Owners filed 163 complaints with NHTSA about the 2003 Kia Sedona (13 crashes, 21 fires, 24 injuries reported). Among 19 model years of this model, it ranks #7 for the most complaints (median 134).
| Most-reported problem | Complaints | |
|---|
| Electrical system | 29 | |
| Air bags | 25 | |
| Engine and engine cooling | 20 | |
| Service brakes, hydraulic | 17 | |
| Vehicle speed control | 13 | |
| Seat belts | 12 | |
| Suspension | 11 | |
| Seats | 9 | |
Crash test ratings
NHTSA 5-Star Safety Ratings for the 2003 Kia Sedona.
| Version | Overall | Frontal | Side | Rollover |
|---|
| 2003 Kia Sedona Van | – | – | – | – |
Fuel economy
EPA ratings for each 2003 Kia Sedona version.
| Version | City MPG | Highway MPG | Combined | Yearly fuel cost |
|---|
| Sedona 3.5 L Automatic 5-spd | 14 | 18 | 16 | $4,200 |
Need this data in your app?
Recalls, complaints, crash ratings and fuel economy as a JSON API. Decode up to 50 VINs per call and get a daily feed of new recalls.
Explore the API →Sources: NHTSA recalls, complaints and 5-Star Safety Ratings, US EPA fuel economy and Transport
Canada's Vehicle Recalls Database (contains information licensed under the Open Government Licence – Canada).
Recalls updated 2026-10-30.