Is your car affected?
Check by VIN to confirm the
exact model and see every recall for it.
Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
US recalls (8)
Seat belts: front, warning light/devices
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator and Lincoln Corsair vehicles equipped with a Revel Audio System that were repaired incorrectly under recall 22V-953. When the driver's seat belt is not buckled and the vehicle is started, the seat belt warning system may activate the audible warning chime for an insufficient amount of time of less than 4 seconds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Risk and remedy
Risk: An audible warning chime that does not properly alert of an unbelted seat belt can increase the risk of injury during a crash.
Remedy: Dealers will update the audio control module software, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C18.
Equipment: electrical, engine block heater
Ford Motor Company (Ford) is recalling certain 2024-2025 Lincoln Nautilus, 2023-2025 Escape, 2023 Lincoln Corsair, 2025 Lincoln Corsair, Maverick, and Bronco Sport vehicles equipped with a 1.5L or 2.0L MPC engine and an engine block heater. The engine block heater may overheat when the vehicle is parked with the block heater plugged in.
Risk and remedy
Risk: An overheated engine block heater can increase the risk of a fire.
Remedy: Dealers will replace the block heater element and inspect the electrical cord, replacing it if necessary, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug coupled, and remove the block heater electrical cord. Owner notification letters were mailed June 9, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S52.
Engine
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Risk and remedy
Risk: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.
Back over prevention: software
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Risk and remedy
Risk: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.
Electrical system: propulsion system, traction battery
Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Risk and remedy
Risk: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Remedy: Owners are advised not to charge battery till the remedy has been completed. Dealers will perform a battery energy control module (BECM) software update, and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on May 30, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S79.
Equipment: other, labels
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Risk and remedy
Risk: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Fuel system, gasoline: fuel injection system, injectors
Ford Motor Company (Ford) is recalling certain 2023 Lincoln Corsair, 2023-2024 Escape, 2024 Mustang, and 2025 Explorer vehicles. The fuel injectors may have been assembled without O-ring support discs, which can result in a fuel leak.
Risk and remedy
Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will install new fuel injector O-rings and O-ring support discs, free of charge. Owner notification letters were mailed on October 7, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S54.
Engine
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Risk and remedy
Risk: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.
Canadian recalls (8)
Show 8 Canadian recalls
High voltage
2026-02-18 · campaign 2026-070
Issue:
On certain vehicles, the software update installed by a Ford dealer during recall 24S79 (Transport Canada recall no. 2024-781) may not be effective. As a result, a second repair is required.
On certain vehicles, a problem inside the high-voltage battery could cause a short circuit. If this happens, there could be a loss of power to the wheels and/or the high-voltage battery could overheat.
Note: This recall replaces Transport Canada recall no. 2025-628. This recall only affects certain plug-in hybrid vehicles (PHEV) equipped with a 2.5 L engine.
Safety Risk:
A loss of power to the wheels could increase the risk of a crash. A battery that overheats can create a fire risk, even while the vehicle is parked and turned off.
Corrective Actions:
To reduce the safety risk, Ford advises that you set the maximum charge setting of your vehicle at 80% and to only use normal EV mode until the recall repairs have been completed. Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the battery energy control module (BECM) and hybrid powertrain control module (HPCM) software. The BECM software will monitor the high-voltage battery and warn you if it detects a problem. If you see this warning, you should contact a dealership to arrange replacement of the high-voltage battery pack.
High voltage
2025-11-14 · campaign 2025-628
This recall was replaced by Transport Canada recall no. 2026-070.
Issue:
On certain vehicles, the software update installed by a Ford dealer during recall 24S79 (Transport Canada recall no. 2024-781) may not be effective. As a result, a second repair is required.
On certain vehicles, a problem inside the high-voltage battery could cause a short circuit. If this happens, there could be a loss of power to the wheels and/or the high-voltage battery could overheat.
Note: This recall only affects certain plug-in hybrid vehicles (PHEV) equipped with a 2.5 L engine.
Safety Risk:
A loss of power to the wheels could increase the risk of a crash. A battery that overheats can create a fire risk, even while the vehicle is parked and turned off.
Corrective Actions:
To reduce the safety risk, Ford advises not to charge your vehicle until the recall repairs have been completed. Ford will notify owners by mail. The corrective actions for this recall are under development.
Engine
2025-05-23 · campaign 2025-281
Issue:
On certain vehicles, the engine block heater could overheat when the block heater is plugged in.
Note: This recall only affects certain vehicles equipped with a 1.5 L or 2.0 L engine and a factory-installed block heater.
Safety Risk:
An engine block heater and/or wiring that overheats or melts could create the risk of a fire.
Corrective Actions:
To reduce the safety risk, Ford advises you not to plug in the engine block heater until the recall repairs have been completed. Ford will notify owners by mail. You can choose to have the dealer remove the block heater, or once the final repair is available, Ford will send you another notice to advise you to take your vehicle to a dealership to replace the block heater element. The dealer will also inspect and, if necessary, replace the block heater electrical cord.
Over-the-air fixVisual system
2025-05-09 · campaign 2025-260
Issue:
On certain vehicles, a software problem could cause the rearview camera image not to display or to freeze when the transmission is shifted into reverse.
Safety Risk:
A rearview camera image that doesn't display correctly could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash.
Corrective Actions:
Ford will notify owners by mail and send a wireless over-the-air software update to eligible vehicles to update the SYNC software. Alternatively, you may schedule an appointment to have the update performed at a Ford dealership.
High voltage
2024-12-20 · campaign 2024-781
Issue:
On certain vehicles, a problem inside the high-voltage battery could cause a short circuit. If this happens, there could be a loss of power to the wheels and/or the high-voltage battery could overheat.
Note: This recall only affects certain plug-in hybrid vehicles (PHEV) equipped with a 2.5 L engine.
Safety Risk:
A loss of power to the wheels could increase the risk of a crash. A battery that overheats can create a fire risk, even while the vehicle is parked and turned off.
Corrective Actions:
To reduce the safety risk, Ford advises not to charge your vehicle until the recall repairs have been completed. Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the battery energy control module (BECM) software. The software will monitor the high-voltage battery and warn you if it detects a problem. If you see this warning, you should contact a dealership to arrange replacement of the high-voltage battery pack.
Engine
2023-05-29 · campaign 2023-309
Issue:
On certain vehicles equipped with a 2.5 L HEV or PHEV engine, a manufacturing problem could lead to an engine failure. In some cases, an engine failure can create the risk of a fire.
Safety Risk:
An engine failure could cause a fire.
Corrective Actions:
Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the powertrain control module (PCM) software or replace the engine, as necessary. To reduce the safety risk, Ford recommends that you should shut off the engine as soon as possible if you hear unusual engine noises, see smoke from the engine compartment, or notice reduced engine power.
Visual system
2023-01-24 · campaign 2023-018
This recall was replaced by Transport Canada Recall No. 2023-288.
Issue:
On certain vehicles equipped with a 360-degree camera, a software problem could cause the rearview camera image to not appear on the SYNC display screen. Canadian regulations require the rearview image to display when the transmission is shifted into reverse gear.
Safety Risk:
A rearview camera image that does not display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash.
Corrective Actions:
Ford will notify owners by mail and instruct you to take your vehicle to a dealer to update the image processing module (IPMB) software.
Seats and restraints
2022-12-27 · campaign 2022-743
Issue:
On certain vehicles, the seat belt reminder chime may not sound for long enough when you start the vehicle, and your seat belt is not buckled. Canadian regulations require both a seat belt reminder sound and visual telltale when a driver is not wearing their seat belt.
Note: This recall only affects vehicles with a Revel audio system.
Safety Risk:
A seat belt warning that does not work correctly may not remind you to buckle your seat belt. Not wearing your seat belt can increase the risk of injury in a crash.
Corrective Actions:
Ford will notify owners by mail and instruct you to take your vehicle to a dealership to update the audio control module software.
Owner complaints (14)
Owners filed 14 complaints with NHTSA about the 2023 Lincoln Corsair. Among 6 model years of this model, it ranks #5 for the most complaints (median 34).
| Most-reported problem | Complaints | |
|---|
| Electrical system | 7 | |
| Unknown or other | 6 | |
| Fuel/propulsion system | 1 | |
| Back over prevention | 1 | |
| Lane departure | 1 | |
| Forward collision avoidance | 1 | |
| Exterior lighting | 1 | |
| Power train | 1 | |
Crash test ratings
NHTSA 5-Star Safety Ratings for the 2023 Lincoln Corsair.
| Version | Overall | Frontal | Side | Rollover |
|---|
| 2023 Lincoln Corsair SUV FWD | 5★ | 5★ | 5★ | 4★ |
| 2023 Lincoln Corsair SUV AWD | 5★ | 5★ | 5★ | 4★ |
Fuel economy
EPA ratings for each 2023 Lincoln Corsair version.
| Version | City MPG | Highway MPG | Combined | Yearly fuel cost |
|---|
| Corsair AWD 2.0 L Automatic (S8) | 21 | 28 | 24 | $2,800 |
| Corsair AWD PHEV 2.5 L Automatic (variable gear ratios) | 34 | 32 | 33 | $2,050 |
| Corsair FWD 2.0 L Automatic (S8) | 22 | 30 | 25 | $2,700 |
Need this data in your app?
Recalls, complaints, crash ratings and fuel economy as a JSON API. Decode up to 50 VINs per call and get a daily feed of new recalls.
Explore the API →Sources: NHTSA recalls, complaints and 5-Star Safety Ratings, US EPA fuel economy and Transport
Canada's Vehicle Recalls Database (contains information licensed under the Open Government Licence – Canada).
Recalls updated 2026-10-30.