Is your car affected?
Check by VIN to confirm the
exact model and see every recall for it.
Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
US recalls (2)
Air bags
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Risk and remedy
Risk: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Fuel system, gasoline: fuel injection system
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Risk and remedy
Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Canadian recalls (3)
Show 3 Canadian recalls
Airbag
2004-10-07 · campaign 2004-366
On certain vehicles, increased clockspring terminal resistance or a back-winding condition of the clockspring may cause the airbag warning lamp to illuminate. Until the problem is remedied, the drivers airbag will not deploy as required in a frontal crash, increasing the risk of injury to the seat occupant. Correction: Dealers will replace the clockspring assembly on vehicles with less than 115 000 kms. Owners of vehicles with over 115 000 kms will be offered extended lifetime warranty on the clockspring.
Fuel system
2000-10-03 · campaign 2000-215
On certain vehicles equipped with the 3.3L or 3.8L engine the Nitrile "O-ring" seals used in the fuel rail may degrade over time and extended exposure to elevated temperatures. This could result in fuel leakage, and, in the presence of an ignition source, an underhood fire could occur. Correction: External seals will be installed at both of the fuel rail crossover tube joints. If the crossover tube joints are leaking or red rust exists in the area, the fuel rail assembly must be replaced.
Emissions
1999-10-29 · campaign 1999-200 · 50 vehicles
On certain vehicles equipped with 3.0 litre engines, the Vehicle Emission Control Information (VECI) labels are those required by the US federal standard. Correction: The correct VECI label, along with installation instructions will be mailed to owners.
Owner complaints (168)
Owners filed 168 complaints with NHTSA about the 2000 Plymouth Voyager/Grand Voyager (22 crashes, 5 fires, 19 injuries, 1 deaths reported). Among 20 model years of this model, it ranks #11 for the most complaints (median 226).
| Most-reported problem | Complaints | |
|---|
| Power train | 34 | |
| Engine and engine cooling | 30 | |
| Air bags | 17 | |
| Electrical system | 15 | |
| Service brakes, hydraulic | 14 | |
| Suspension | 12 | |
| Vehicle speed control | 10 | |
| Seat belts | 10 | |
Crash test ratings
NHTSA 5-Star Safety Ratings for the 2000 Plymouth Voyager/Grand Voyager.
| Version | Overall | Frontal | Side | Rollover |
|---|
| 2000 Plymouth Voyager | – | – | – | – |
Fuel economy
EPA ratings for each 2000 Plymouth Voyager/Grand Voyager version.
| Version | City MPG | Highway MPG | Combined | Yearly fuel cost |
|---|
| Voyager/Grand Voyager 2WD 2.4 L Automatic 3-spd | 18 | 24 | 20 | $3,350 |
| Voyager/Grand Voyager 2WD 3.0 L Automatic 4-spd | 16 | 23 | 19 | $3,550 |
| Voyager/Grand Voyager 2WD 3.3 L Automatic 4-spd | 16 | 23 | 19 | $3,550 |
| Voyager/Grand Voyager 2WD 3.3 L Automatic 4-spd | 16 | 23 | 19 | $3,550 |
| Voyager/Grand Voyager 2WD 3.8 L Automatic 4-spd | 15 | 22 | 18 | $3,700 |
Need this data in your app?
Recalls, complaints, crash ratings and fuel economy as a JSON API. Decode up to 50 VINs per call and get a daily feed of new recalls.
Explore the API →Sources: NHTSA recalls, complaints and 5-Star Safety Ratings, US EPA fuel economy and Transport
Canada's Vehicle Recalls Database (contains information licensed under the Open Government Licence – Canada).
Recalls updated 2026-10-30.