Is your car affected?
Check by VIN to confirm the
exact model and see every recall for it.
Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
US recalls (3)
Fuel system, gasoline: storage
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Risk and remedy
Risk: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
Latches/locks/linkages: doors, latch
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Risk and remedy
Risk: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Air bags: frontal
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Risk and remedy
Risk: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Canadian recalls (4)
Show 4 Canadian recalls
Suspension
2006-08-15 · campaign 2006-199
On certain Aztek (AWD), Montana (AWD), Relay (AWD), RendezVous (AWD), RendezVous (FWD), Silhouette (AWD), Terraza (AWD), Terraza (FWD), Uplander (AWD) and Venture (AWD) vehicles equipped with independent rear suspension, when operated in extreme cold temperature and on rough roads, water and salt can intrude past the ball joint seal. The combination of theses conditions may then lead to premature wear of the ball joint. If the ball joint wear progresses to the point of separation from the lower control arm, a loss of vehicle control may occur. Correction: Dealers will replace both ball joints with new ball joints which have a revised boot and ball stud to improve the seal to the ball stud shaft.
Other
2004-12-22 · campaign 2004-446
On certain vehicles equipped with second-row bucket seats or captain's chairs and power sliding door on the passenger side, if a passenger uses the interior handle to open the power sliding door and holds onto the handle while it is being opened by the motor, the passenger's arm may be pushed into the seat back or armrest and a wrist or lower arm injury may result. Correction: Dealers will replace the original interior power sliding door handle. The original handles are offset from the door panel and a passenger can wrap his or her fingers around them. The replacement door handles are essentially flush with the door trim, preventing a passenger from gripping them in the same fashion.
Airbag
2002-08-13 · campaign 2002-151
Certain vehicles may have a driver's side airbag inflator that could fracture at a weld during a deployment. Pieces of the inflator could strike and injure vehicle occupants and the airbag cushion would not inflate fully, reducing the capacity of the bag to protect the driver. Correction: Dealers are to inspect and if necessary replace the driver side airbag module assembly.
Other
2001-11-14 · campaign 2001-272
Certain vehicles have an improperly programmed vehicle theft deterrent system. Correction: dealers will reprogram the system.
Owner complaints (126)
Owners filed 126 complaints with NHTSA about the 2002 Pontiac Montana (3 crashes, 1 fires, 6 injuries reported). Among 11 model years of this model, it ranks #4 for the most complaints (median 81).
| Most-reported problem | Complaints | |
|---|
| Engine and engine cooling | 24 | |
| Fuel system, gasoline | 12 | |
| Exterior lighting | 12 | |
| Service brakes, hydraulic | 11 | |
| Power train | 11 | |
| Visibility | 11 | |
| Equipment | 10 | |
| Structure | 10 | |
Crash test ratings
NHTSA 5-Star Safety Ratings for the 2002 Pontiac Montana.
| Version | Overall | Frontal | Side | Rollover |
|---|
| 2002 Pontiac Montana w/SAB. | – | – | – | – |
Fuel economy
EPA ratings for each 2002 Pontiac Montana version.
| Version | City MPG | Highway MPG | Combined | Yearly fuel cost |
|---|
| Montana AWD 3.4 L Automatic 4-spd | 16 | 22 | 18 | $3,700 |
| Montana FWD 3.4 L Automatic 4-spd | 17 | 24 | 20 | $3,350 |
Need this data in your app?
Recalls, complaints, crash ratings and fuel economy as a JSON API. Decode up to 50 VINs per call and get a daily feed of new recalls.
Explore the API →Sources: NHTSA recalls, complaints and 5-Star Safety Ratings, US EPA fuel economy and Transport
Canada's Vehicle Recalls Database (contains information licensed under the Open Government Licence – Canada).
Recalls updated 2026-10-30.