Is your car affected?
Check by VIN to confirm the
exact model and see every recall for it.
Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
US recalls (3)
Latches/locks/linkages: doors, latch
CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
Risk and remedy
Risk: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Fuel system, gasoline: storage, tank assembly
ON SPORT UTILITY VEHICLES, THERE IS A BREATHER HOSE THAT ATTACHES TO THE NOZZLE OF THE ON-BOARD REFUELING VAPOR RECOVERY (ORVR) VALVE, WHICH IS LOCATED ON THE TOPSIDE OF THE FUEL TANK. THE BREATHER HOSE IS ATTACHED WITH A CLAMP, WHOSE "TABS" FACE IN THE UPWARD DIRECTION. WHEN THE VEHICLE WAS CRASHED UNDER THE NEW CAR ASSESSMENT PROGRAM (NCAP) TEST (I.E., 35 MPH FRONTAL BARRIER CRASH), THE CLAMP "TABS" CONTACTED THE UNDERSIDE OF THE BODY DUE TO MOVEMENT OF THE FUEL TANK, CAUSING THE NOZZLE TO BREAK.
Risk and remedy
Risk: IN THE WORST CASE, NOZZLE BREAKAGE COULD RESULT IN FUEL LEAKAGE IF THE VEHICLE ROLLS-OVER AFTER A HIGH SPEED FRONTAL CRASH.
Remedy: DEALERS WILL ROTATE THE SPECIFIED CLAMP. OWNER NOTIFICATION BEGAN SEPTEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Service brakes, hydraulic: foundation components, master cylinder
VEHICLE DESCRIPTION: SPORT UTIITY VEHICLES. THE RESERVOIR FILLER CAP OF THE BRAKE MASTER CYLINDER MAY INDUCE A VACUUM, INTRODUCING SOME AIR INTO THE BRAKE MASTER CYLINDER RESERVOIR. THIS COULD CAUSE ABNORMAL BRAKE NOISE AND INCREASED PEDAL STROKE WHEN THE BRAKES ARE APPLIED.
Risk and remedy
Risk: THE INCREASED PEDAL STROKE WILL LENGTHEN THE STOPPING DISTANCE OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL BLEED THE AIR FROM THE BRAKE LINES AND REPLACE THE RESERVOIR FILLER CAP. OWNER NOTIFICATION BEGAN JULY 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Canadian recalls (3)
Show 3 Canadian recalls
Other
2004-04-07 · campaign 2004-127
On certain vehicles, if the rear side doors are closed very hard with the Child Protection Lock (CPL) lever in the lock position, there is a possibility that the lock lever may contact the body panel due to insufficient clearance, causing the CPL lever to move into the unlock position. This condition could allow the doors to be opened with the inside door handles while the operator believes that the child protection lock was activated. Correction: Dealer will shorten the CPL levers.
Fuel system
2002-07-30 · campaign 2002-142
On certain vehicles, there is a breather hose that attaches to the nozzle of the on-board refueling vapor recovery (ORVR) valve, which is located on the topside of the fuel tank. The breather hose is attached with a clamp, whose "tabs" face in the upward direction. When the vehicle was crashed under the new car assessment program (NCAP) test (i.e., 35 mph frontal barrier crash), the clamp "tabs" contacted the underside of the body due to movement of the fuel tank, causing the nozzle to break. In the worst case, nozzle breakage could result in fuel leakage if the vehicle rolls-over after a high speed frontal crash. Correction: Dealers will rotate the specified clamp.
Brakes
2001-07-03 · campaign 2001-188
Certain sport utiity vehicles. The reservoir filler cap of the brake master cylinder may induce a vacuum, introducing some air into the brake master cylinder reservoir. This could cause abnormal brake noise and increased pedal stroke when the brakes are applied. The increased pedal stroke will lengthen the stopping distance of the vehicle, increasing the risk of a crash. Correction: Dealers will bleed the air from the brake lines and replace the reservoir filler cap.
Owner complaints (137)
Owners filed 137 complaints with NHTSA about the 2001 Toyota Highlander (19 crashes, 2 fires, 11 injuries reported). Among 28 model years of this model, it ranks #19 for the most complaints (median 207).
| Most-reported problem | Complaints | |
|---|
| Visibility | 23 | |
| Engine and engine cooling | 17 | |
| Service brakes, hydraulic | 15 | |
| Vehicle speed control | 15 | |
| Structure | 13 | |
| Power train | 13 | |
| Air bags | 10 | |
| Tires | 9 | |
Fuel economy
EPA ratings for each 2001 Toyota Highlander version.
| Version | City MPG | Highway MPG | Combined | Yearly fuel cost |
|---|
| Highlander 2WD 2.4 L Automatic 4-spd | 19 | 25 | 22 | $3,050 |
| Highlander 2WD 3.0 L Automatic 4-spd | 17 | 21 | 18 | $3,700 |
| Highlander 4WD 2.4 L Automatic 4-spd | 17 | 22 | 19 | $3,550 |
| Highlander 4WD 3.0 L Automatic 4-spd | 16 | 21 | 18 | $3,700 |
Need this data in your app?
Recalls, complaints, crash ratings and fuel economy as a JSON API. Decode up to 50 VINs per call and get a daily feed of new recalls.
Explore the API →Sources: NHTSA recalls, complaints and 5-Star Safety Ratings, US EPA fuel economy and Transport
Canada's Vehicle Recalls Database (contains information licensed under the Open Government Licence – Canada).
Recalls updated 2026-10-30.