Clean Feeds
Home › Recalls › Volkswagen › Touareg › 2004

2004 Volkswagen Touareg recalls, complaints and safety ratings

There are 4 US recalls for the 2004 Volkswagen Touareg, and 5 in Canada. Owners filed 231 complaints with NHTSA, most often about power train.

4US recalls
0urgent recalls
231owner complaints
–overall crash rating

Is your car affected?

Check by VIN to confirm the exact model and see every recall for it.

Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.

US recalls (4)

Fuel system, gasoline: delivery, fuel pump

2017-09-20 · campaign 17V583000 · 73,941 vehicles

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2004-2007 Touareg vehicles. These gasoline-powered vehicles have a fuel filter flange that may crack, allowing fuel to leak.

Risk and remedy

Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Volkswagen will notify owners, and dealers will inspect the fuel filter flange for cracks, replacing the flange if cracks are found. If no cracks are found, a protective cover will be installed onto the filter flange. These repairs will be performed free of charge. The recall began March 9, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20Ai.

Seat belts

2004-12-15 · campaign 04V592000 · 50,483 vehicles

CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS.

Risk and remedy

Risk: WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED, INCREASING THE RISK OF INJURIES OR DEATH.

Remedy: DEALERS WILL PERMANENTLY INSTALL A 'CLIP' IN EACH OF THE TWO REAR OUTBOARD SEAT BELTS. THE CLIPS WILL PREVENT UNWANTED DEACTIVATION OF THE ALR MODE WITH CHILD SEAT INSTALLATIONS. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS SHOULD CONTACT VW AT 1-800-822-8987.

Seat belts: rear/other

2004-05-19 · campaign 04V233000 · 24,269 vehicles

ON CERTAIN SPORT UTILITY VEHICLES, THE REAR SEAT BELT LATCH ATTACHMENT BOLT MAY HAVE BEEN INSUFFICIENTLY RIVETED.

Risk and remedy

Risk: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE BELT BUCKLE. OWNER NOTIFICATION BEGAN ON JUNE 21, 2004. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.

Electrical system: wiring

2003-07-25 · campaign 03V266000 · 670 vehicles

ON CERTAIN SPORT UTILITY VEHICLES, THE TIRE PRESSURE MONITORING SYSTEM (TPMS) WIRING HARNESS MAY HAVE BEEN IMPROPERLY ROUTED DURING ASSEMBLY. AN IMPROPERLY ROUTED TPMS WIRING HARNESS MAY CONTACT THE PARKING BRAKE CABLE SPRING.

Risk and remedy

Risk: IF THIS HAPPENS, THE TPMS WIRING CIRCUIT COULD BE INTERRUPTED, RESULTING IN AN INOPERATIVE TPMS, AND CAUSING A SHORT-TO-GROUND CONDITION THAT COULD POTENTIALLY RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE TPMS WIRING HARNESS ROUTING AND, IF NECESSARY, CORRECT THE WIRING HARNESS ROUTING. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT VWOA AT 1-800-893-5298.

Canadian recalls (5)

Show 5 Canadian recalls

Fuel system

2017-09-20 · campaign 2017-458

On certain vehicles, the fuel pump flange may develop fine cracks or fissures, which could result in a fuel leak. Leaking fuel, in the presence of an ignition source, could lead to a fire causing injury and/or damage to property. Correction: Dealers will inspect for cracks and replace the fuel filter flange if cracks are found. If no cracks are detected, a protective cover will be applied to the filter flange to prevent oxidization and future formation of cracks.

Label

2004-07-21 · campaign 2004-259 · 882 vehicles

Certain vehicles do not comply with the requirements of CMVSS 120. The tire pressure label, located on the driver's side B-pillar, does not indicate the vehicle GVWR and GAWR or the recommended wheel rim size. The tire size, rim size and inflation pressure information was also not given on the compliance certification label. However, the combination of the tire information label and the certification label adjacent to each other on the driver side B-pillar provides the GAWR, GVWR, tire size and inflation pressure information. Correction: Since this does not pose any safety risk, no corrective action is required.

Other

2004-06-07 · campaign 2004-187

Certain Volkswagen Phaeton, Touareg, and Audi A8L vehicles do not comply with the requirements of CMVSS 114. The steering wheel does not lock when the key is removed from the ignition switch using the optionally provided override device that permits key removal in the event of electrical system failure or when the transmission is not in the PARK position. Correction: Since this does not pose any safety risk, no corrective action is required.

Seats and restraints

2004-05-17 · campaign 2004-163

On certain vehicles, the rear seat safety belt latch attachment bolt may be insufficiently riveted, which could result in a reduced capability of the belt latch to withstand the applied loads. During a crash, the occupant may not be restrained as intended, which could result in injuries. Correction: Dealer will inspect and, if necessary, replace the seat belt buckle.

Electrical

2003-07-29 · campaign 2003-177 · 63 vehicles

On certain vehicles, improperly routed Tire Pressure Monitoring System (TPMS) wiring harness may contact the parking brake cable spring. If this occurs, the TPMS wiring circuit may be interrupted, resulting in an inoperative TPMS and a potential short-to-ground condition that could result in a fire. Correction: Dealer will re-route the TPMS wiring harness.

Owner complaints (231)

Owners filed 231 complaints with NHTSA about the 2004 Volkswagen Touareg (9 crashes, 5 fires, 6 injuries reported). Among 14 model years of this model, it ranks #1 for the most complaints (median 28).

Most-reported problemComplaints
Power train50
Electrical system49
Tires36
Air bags27
Fuel/propulsion system23
Engine and engine cooling22
Vehicle speed control22
Suspension20

Crash test ratings

NHTSA 5-Star Safety Ratings for the 2004 Volkswagen Touareg.

VersionOverallFrontalSideRollover
2004 Volkswagen Touareg 4-Dr. w/SAB––––

Fuel economy

EPA ratings for each 2004 Volkswagen Touareg version.

VersionCity MPGHighway MPGCombinedYearly fuel cost
Touareg 3.2 L Automatic (S6)131915$5,500
Touareg 4.2 L Automatic (S6)121714$5,850
Touareg 5.0 L Automatic (S6)152218$5,300
Need this data in your app?
Recalls, complaints, crash ratings and fuel economy as a JSON API. Decode up to 50 VINs per call and get a daily feed of new recalls.
Explore the API →

Sources: NHTSA recalls, complaints and 5-Star Safety Ratings, US EPA fuel economy and Transport Canada's Vehicle Recalls Database (contains information licensed under the Open Government Licence – Canada). Recalls updated 2026-10-30.