Is your car affected?
Check by VIN to confirm the
exact model and see every recall for it.
Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
US recalls (3)
Air bags: frontal, driver side
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk and remedy
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.
Equipment: electrical, navigational system(global positioning system)
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Risk and remedy
Risk: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Equipment: other, labels
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE LABEL DENOTING THE TIRE AND LOADING PRESSURE INFORMATION IS INCORRECT.
Risk and remedy
Risk: A MISPRINTED LABEL WOULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL THE CORRECT LABELS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Canadian recalls (3)
Show 3 Canadian recalls
Accessories
2010-11-08 · campaign 2010-396 · 87 vehicles
On certain vehicles, there is a possibility of overheating issues of batteries in the Garmin nüvi® 760 when certain batteries manufactured within a limited date code range are used in certain Garmin nüvi® 760 models with a specific printed circuit board (PCB) design. The interaction of these factors can, in some circumstances, increase the possibility of overheating, which may lead to a fire. Correction: Dealers will direct customers who have an affected unit to the Garmin Web site, which explains how to verify if their units are involved and includes procedures to follow for product exchange.
Label
2006-09-27 · campaign 2006-237
Certain vehicles fail to comply with the requirements of CMVSS 110. The Tire and Loading Information Label contains incorrect tire inflation pressure value. If the vehicle is equipped with SST tires and the inflation pressure is set to 35 PSI (incorrect pressure listed on the label), the Tire Pressure Monitoring System (TPMS) may set a warning message "Low Tire Press. Check Tires". Correction: Owners will be provided with labels and installation instructions.
Electrical
2005-11-17 · campaign 2005-365 · 465 vehicles
On certain vehicles, the positive battery cable may wear against the starter solenoid. The resulting chafe damage could develop into an electrical short. This can be noticed in different ways. If the vehicle is parked, smoke may appear from under the hood and/or it may be impossible to start the car. If the short circuit happens during driving, not only will the engine stall, but the electrical power could also be lost, resulting in warning lamps being deactivated. Correction: Dealers will relocate the battery cable.
Owner complaints (12)
Owners filed 12 complaints with NHTSA about the 2006 Volvo S80 (1 crashes reported). Among 18 model years of this model, it ranks #12 for the most complaints (median 24).
| Most-reported problem | Complaints | |
|---|
| Vehicle speed control | 3 | |
| Engine and engine cooling | 3 | |
| Electrical system | 3 | |
| Seat belts | 2 | |
| Suspension | 2 | |
| Air bags | 2 | |
| Exterior lighting | 1 | |
| Service brakes, hydraulic | 1 | |
Crash test ratings
NHTSA 5-Star Safety Ratings for the 2006 Volvo S80.
| Version | Overall | Frontal | Side | Rollover |
|---|
| 2006 Volvo S80 4-DR. w/SAB | – | – | – | – |
Fuel economy
EPA ratings for each 2006 Volvo S80 version.
| Version | City MPG | Highway MPG | Combined | Yearly fuel cost |
|---|
| S80 AWD 2.5 L Automatic 5-spd | 17 | 25 | 20 | $4,100 |
| S80 FWD 2.5 L Automatic 5-spd | 19 | 27 | 22 | $3,750 |
Need this data in your app?
Recalls, complaints, crash ratings and fuel economy as a JSON API. Decode up to 50 VINs per call and get a daily feed of new recalls.
Explore the API →Sources: NHTSA recalls, complaints and 5-Star Safety Ratings, US EPA fuel economy and Transport
Canada's Vehicle Recalls Database (contains information licensed under the Open Government Licence – Canada).
Recalls updated 2026-10-30.