Is your car affected?
Check by VIN to confirm the
exact model and see every recall for it.
Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
US recalls (3)
Electrical system: propulsion system, traction battery
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Risk and remedy
Risk: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.
Engine and engine cooling: engine, engine control module (ecu/ecm)
Volvo Car USA, LLC (Volvo Car) is recalling certain 2022-2023 S60, V60, S90L, XC60, and XC90 vehicles. An electronic control module (ECM) software error may prevent the combustion engine from starting, causing a loss of drive power.
Risk and remedy
Risk: The vehicle may lose drive power as the high voltage battery is depleted, increasing the risk of a crash.
Remedy: Dealers will update the ECM software, free of charge. Owner notification letters are expected to be mailed December 8, 2022. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10198.
Seat belts: rear/other, retractor
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Risk and remedy
Risk: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 13, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10111.
Canadian recalls (3)
Show 3 Canadian recalls
High voltage
2025-03-20 · campaign 2025-147 · 585 vehicles
Issue:
On certain vehicles, there could be a problem inside the high-voltage battery. As a result, the battery modules could overheat and short circuit.
Note: This recall only affects certain plug-in hybrid (PHEV) models.
Safety Risk:
A short circuit in the high-voltage battery can create a fire risk, even while the vehicle is parked and turned off.
Corrective Actions:
To reduce the safety risk, Volvo advises not to charge your vehicle until the recall repairs have been completed. Volvo will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the high-voltage battery module(s). The dealer will also install an advanced diagnostic software that will monitor the high-voltage battery and warn you if it detects a problem. If you see this warning, you should contact a dealership to arrange replacement of the affected high-voltage battery module(s).
Over-the-air fixVisual system
2022-10-20 · campaign 2022-595
Issue:
On certain vehicles, a software problem could cause the top-view camera to display instead of the rearview camera image when you are reversing. Canadian regulations require the rearview image to display when reversing.
Note: This recall only affects vehicles equipped with a 360-degree park assist camera.
Safety Risk:
A rearview camera image that does not display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash.
Corrective Actions:
Volvo will notify owners in writing and send a wireless over-the-air update to each vehicle. If the update cannot be completed successfully, or for vehicles without over-the-air (OTA) update capability, Volvo will instruct you to schedule an appointment to have the update performed by a dealer.
Seats and restraints
2021-09-01 · campaign 2021-540
Issue:
On certain vehicles, the passenger seat belt assemblies may contain defective automatic locking retractors (ALR). As a result, the seat belts may not properly lock to secure a child seat.
Note: The vehicle's lower universal anchorage system (UAS) is not affected by this defect and may still be used to secure a child seat.
Safety Risk:
A seat belt that is used to secure a child restraint but is not properly locked could increase the risk of injury in a crash.
Corrective Actions:
Volvo will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the seat belts. They will be replaced, if necessary.
Owner complaints (1)
Owners filed 1 complaints with NHTSA about the 2022 Volvo V60. Among 9 model years of this model, it ranks #7 for the most complaints (median 2).
| Most-reported problem | Complaints | |
|---|
| Latches/locks/linkages | 1 | |
| Electrical system | 1 | |
Crash test ratings
NHTSA 5-Star Safety Ratings for the 2022 Volvo V60.
| Version | Overall | Frontal | Side | Rollover |
|---|
| 2022 Volvo V60 CC T5 AWD SW AWD | 5★ | 4★ | 5★ | 5★ |
| 2022 Volvo V60 T8 Polestar Engineered SW AWD | – | – | – | – |
Fuel economy
EPA ratings for each 2022 Volvo V60 version.
| Version | City MPG | Highway MPG | Combined | Yearly fuel cost |
|---|
| V60 T8 AWD Recharge 2.0 L Automatic (S8) | 28 | 33 | 30 | $2,750 |
| V60 T8 AWD Recharge ext. Range 2.0 L Automatic (S8) | 30 | 33 | 31 | $2,650 |
| V60CC T5 AWD 2.0 L Automatic (S8) | 22 | 31 | 25 | $3,300 |
Need this data in your app?
Recalls, complaints, crash ratings and fuel economy as a JSON API. Decode up to 50 VINs per call and get a daily feed of new recalls.
Explore the API →Sources: NHTSA recalls, complaints and 5-Star Safety Ratings, US EPA fuel economy and Transport
Canada's Vehicle Recalls Database (contains information licensed under the Open Government Licence – Canada).
Recalls updated 2026-10-30.