Is your car affected?
Check by VIN to confirm the
exact model and see every recall for it.
Recalls are issued for a make, model and model year. Whether the repair has already been done on one specific car is known only to its manufacturer and dealers. Check your vehicle's official status at nhtsa.gov/recalls or with a dealer.
US recalls (3)
Equipment: electrical, navigational system(global positioning system)
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Risk and remedy
Risk: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Steering: linkages, tie rod assembly
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Risk and remedy
Risk: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Visibility: windshield wiper/washer
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Risk and remedy
Risk: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Canadian recalls (5)
Show 5 Canadian recalls
Accessories
2010-11-08 · campaign 2010-396 · 87 vehicles
On certain vehicles, there is a possibility of overheating issues of batteries in the Garmin nüvi® 760 when certain batteries manufactured within a limited date code range are used in certain Garmin nüvi® 760 models with a specific printed circuit board (PCB) design. The interaction of these factors can, in some circumstances, increase the possibility of overheating, which may lead to a fire. Correction: Dealers will direct customers who have an affected unit to the Garmin Web site, which explains how to verify if their units are involved and includes procedures to follow for product exchange.
Steering
2006-05-08 · campaign 2006-108
On certain vehicles, deformation at high loads may cause loss of clamping force of the outer tie rod and allow the nut to loosen. This may eventually lead to a fatigue fracture of the outer tie rod assembly. Tie rod separation could lead to a loss of steering control which could result in a vehicle crash. Correction: Dealers will replace outer tie rods with updated versions.
Visual system
2006-04-26 · campaign 2006-093
On certain vehicles the windshield wiper pivot splines may be damaged due to failure to remove snow from the windshield. This would result in a loss of wiper operation and resultant detriment to vision. Correction: Dealers will replace wiper arms and retaining nuts.
Seats and restraints
2006-03-27 · campaign 2006-066
Certain Volvo 850, S40, V40, V50, V70, XC70 and XC90 equipped with integrated child booster cushions were incorrectly labelled during vehicle assembly. The label indicates that the booster cushion can be used for children weighing between 15 and 36 kg (33 and 80 lb). CMVSS 213 states that the minimum weight for use must be 18 kg (40 lb). Should an underweight child be placed in the booster cushion and the vehicle is involved in a crash, the child may have a greater risk of injury. Correction: Volvo Canada will send a letter to owners explaining this problem and will supply updated weight limit decal to be applied to each side window.
Electrical
2005-11-17 · campaign 2005-365 · 465 vehicles
On certain vehicles, the positive battery cable may wear against the starter solenoid. The resulting chafe damage could develop into an electrical short. This can be noticed in different ways. If the vehicle is parked, smoke may appear from under the hood and/or it may be impossible to start the car. If the short circuit happens during driving, not only will the engine stall, but the electrical power could also be lost, resulting in warning lamps being deactivated. Correction: Dealers will relocate the battery cable.
Owner complaints (53)
Owners filed 53 complaints with NHTSA about the 2006 Volvo XC90 (4 crashes, 4 fires, 3 injuries reported). Among 22 model years of this model, it ranks #6 for the most complaints (median 38).
| Most-reported problem | Complaints | |
|---|
| Electrical system | 16 | |
| Tires | 8 | |
| Engine | 6 | |
| Unknown or other | 5 | |
| Exterior lighting | 4 | |
| Wheels | 3 | |
| Fuel system, gasoline | 3 | |
| Structure | 3 | |
Crash test ratings
NHTSA 5-Star Safety Ratings for the 2006 Volvo XC90.
| Version | Overall | Frontal | Side | Rollover |
|---|
| 2006 Volvo XC90 4-DR. w/SAB | – | – | – | 4★ |
Fuel economy
EPA ratings for each 2006 Volvo XC90 version.
| Version | City MPG | Highway MPG | Combined | Yearly fuel cost |
|---|
| XC90 AWD 2.5 L Automatic (S5) | 15 | 20 | 17 | $4,850 |
| XC90 AWD 4.4 L Automatic (S6) | 13 | 19 | 15 | $5,500 |
| XC90 FWD 2.5 L Automatic (S5) | 15 | 21 | 18 | $4,550 |
Need this data in your app?
Recalls, complaints, crash ratings and fuel economy as a JSON API. Decode up to 50 VINs per call and get a daily feed of new recalls.
Explore the API →Sources: NHTSA recalls, complaints and 5-Star Safety Ratings, US EPA fuel economy and Transport
Canada's Vehicle Recalls Database (contains information licensed under the Open Government Licence – Canada).
Recalls updated 2026-10-30.